《ky筛下漏斗施工方案.doc》由会员分享,可在线阅读,更多相关《ky筛下漏斗施工方案.doc(15页珍藏版)》请在三一文库上搜索。
1、actions using rules, and in the process of the concentration of disciplinary ruling, not convergence, not pull back as heavy or heavier punishment. Discipline focused discipline process at least 18 since the five-year, five years is to pay close attention to the Central implementation eight provisio
2、ns and anti-four winds. Fourth chapter to suspected illegal party disciplinary actions and distinguish between five different circumstances, provides for specific provisions respectively, effective cohesion to achieve party discipline and State Law 9. One is the 27th article of the Ordinance provide
3、s that party members found in the disciplinary review of corruption bribery, dereliction of duty and other alleged offences under criminal law, should be given to withdraw party posts, expelled from or placed on probation within the party disciplinary action. Second, article 28th of the regulations
4、in the discipline of the party organization . Disciplinary punishment against life , Chapter 6. 3, annex Annex part of supplementary provisions, such as the permission, interpretation of the regulations, as well as the timing and retroactive, and so on. 11 (three) learning understanding Ordinance ne
5、ed grasp of several focus problem first a problem-on violation political discipline behavior new Ordinance sixth chapter put political discipline as six big discipline of first, is main on opposition of led and opposition of basic theory, and line, and basic programme of, and basic experience, and b
6、asic requirements of disciplinary behavior made disposition provides, especially will 18 big yilai Central proposed strict political discipline and political rules of requirements and practice results into for discipline provisions, Added jump on the central policy, clique, fight reviews, without pr
7、inciples and disregard the disciplinary provisions. These are the partys 18 since the comprehensive practice of strictly administering the party in the process of combining the rich content. (1) jump on the central policy violate the partys centralized and unified this issue is made under provisions
8、 of the party Constitution. Party Constitution stipulated in master uphold democratic centralism is the party building must adhere to one of the four basic requirements. This items principles is party of fundamental Organization principles, is mass line in party of life in the of using, it requireme
9、nts must full develop party democratic, respect members of subject status, guarantees members of democratic right, full play levels party and members of enthusiasm and creative, while, also must implemented right of concentrated, guarantee party of solidarity unified and action consistent, guarantee
10、 party of decided get quickly and effective of implementation. Central in developed major approach policy Shi, through different of channel and way, full heard about party and members of views recommends, but 12 is some people face to face not said, and behind blather will Shang not said, and will H
11、ou blather stage not said, and Taiwan Xia blather, actually not only disrupt has people thought, some caused serious consequences, damage has party of concentrated unified, hamper has central approach policy of implement implementation, also serious violation has democratic centralism of principles.
12、 No doubt, shall, in accordance with the regulations stipulated in the 46th of appropriate sanctions. Without serious consequences, the criticism should be given education or the appropriate organization. (2) violate the partys solidarity and unity to the new section 48th 扩建厂房筛下漏斗及脱介振动筛吊装施工方案 编制人: 审
13、核人: 安全: 质量: 批准人:中国化学工程第十四建设有限公司宁夏宝丰能源项目经理部2014年5月11日目录1.工程概况: 32.施工准备: 3 2.1设计准备 3 2.2施工组织 . 32.3 施工机具 . 42.4 施工现场 42.5 基础验收交接 43. 施工方案 43.1吊装顺序 43.2吊点的选择 43.3受力分析荷载计算 43.4吊车机具选择 73.5吊车索具选择 . 83.6施工机具布置 83.7吊装过程 84. 技术措施 95.安全措施 96、成品保护 101.工程概况 本工程是宁夏宝丰能源集团有公司选煤厂扩建工程扩建主厂房筛下漏斗及脱介振动筛吊装工程,设计单位为北京华宇工程有
14、限公司。本次吊装的漏斗及脱介振动筛具有自重较大、筛体尺寸较大的特点,截至目前,厂房尚未安装任何吊装器具及桁车,且吊装场地十分狭小(因为原旧厂房上空管道影响,经现场核实,原计划的吊车进入宽度及高度不够)筛子进入时需要另行选择吊装口位置,造成回转半径过大和进入角度比较困难,这是本次吊装的重点难点所在,装车转运时,必须租用25吨吊车两台和20吨平板车配合运输。所吊设备名称及参数:名称:中煤(矸石)脱介振动筛;参数: 7120*4500mm(长*宽),重12.9吨两个;精煤脱介振动筛参数:8340*4500mm(长*宽),重16.9吨;两个筛下漏斗为9020*3870(长*宽),单重5.3吨; 792
15、0*3870mm(长*宽),单重5吨 。设备安装高度在+9.50米平面上,预计于2014年5月18日实施吊装。2.施工准备2.1设计准备提前编制专项吊装方案,核实漏斗筛体实际重量和尺寸,核实吊着站位,核实吊着参数,确定吊车选型,计划吊装步骤,吊装日期前一天对施工人员进行技术安全交底,解说方案和图纸,吊装当天重复吊装要点。2.2施工组织(吊装作业领导小组) 吊装作业领导小组成员:组长:杨卫凯(总负责人)副组长:于述鹏(全面协调)技术负责人:张林强(方案设定、技术协调)总指挥:尚东北(现场起重作业总指挥)副总指挥:王聪(协助指挥)安监人员:李文辉组班长:杨建平作业人员:高富雨、张中奎、王汉生、刘庆
16、刚及其他班组成员2.3 施工机具机具名称技术参数吊车300吨汽车吊1台运输车辆20吨平板汽车一辆倒链2台10吨倒链钢丝绳6*37+FC-27 51m卡环10T若干2.4 施工现场2.4.1施工现场情况三通一平,设备的场内运输路线畅通,吊车站位地基已经夯实;2.4.2设备的运输:二次运输中设备要求固定牢固,运输距离约为1000米,无需倒运。2.5 基础验收交接安装前,由建设单位、监理单位主持对基础进行验收,钢柱钢梁.筛子立柱焊接质量,焊接强度等达到设计要求,并办理交接手续。3. 施工方案3.1吊装顺序:根据设备布置,按照从里到外,不影响其他设备进入原则的顺序进行吊装。具体顺序筛下溜槽.筛前溜槽.
17、立柱.筛子。3.2吊点的选择 吊点的选择:新扩建厂房南侧,及北侧东面夹到。3.3受力分析荷载计算3.3.1 荷载计算在起吊作业中,吊具、索具会出现冲击震动和承受不均衡荷载的情况,提升系统的最大荷载会在快速起吊的降落以及紧急制动时出现。对吊具、索具进行核算,其计算荷载: Q=K1K2(Q+q)=1.2*1.2(16.9+0.1)=22.44吨K1-动载系数,选择值见表K2-不均衡系数,一般取1.2Q-被吊设备的重量q-吊具索具重量(约100kg)起吊牵引系统(或制动系统)的工作方式1.1通过滑轮组用人力绞车或绞磨牵引起吊设备时1.2直接用人力绞车或绞磨牵引起吊设备时1.2通过滑轮组用机动绞车或绞
18、磨、拖拉机或汽车牵引起吊时1.2直接用绞车或绞磨、拖拉机或汽车牵引起吊时1.1通过滑轮组用制动器控制的制动系统1.1直接用制动器控制的制动系统1.13.3.2吊装器具及回转半径等参数确定与计算:1. 吊装索具的选择。首先选择吊装点,吊装点的选择的原则:设备制造厂指定位置,吊装索具易于捆绑位置、各点受力均衡稳定。根据以上原则,首先该设备自带的吊孔(即设备制造厂商制定位置,位于筛子四个角),为多点(四点)吊装。按照多点吊装绳扣与水平方向的夹角一般取45-60之间,本次吊装调整夹角为45,计算单根绳扣长度(根据筛体尺寸及绳扣与水平方向夹角,可得以下示意图)由上图可知:A点到B点的距离:LAB*LAB
19、=8370*8370+2250*2250 LAC=LBC=4515 LAB/cos45=4515/0.707=6386即单根绳扣长度=6.386m,共需绳扣长度(8根,每个吊装孔两根),L=6.386X8=51m 2.吊装分两个位置吊装 (1)北侧因为扩建主厂房东侧原厂房及扩建厂房本身钢柱及钢梁的限制且这两台振动筛自重较大为16.9吨,所以吊着的起吊高度为23.5米。因场地限制吊车的回转半径为33米,因此得出吊车的出臂长度为40.5米。(附图) (2)扩建主厂房南侧由于在框架东面上空4米处有生产管道通过,所以吊车需站在管道的东侧,有现场确定吊车的作业半径为28米,起重高度为16.5米,因此得到
20、吊车的出臂长度为32.5米。根据以上计算结果及吊车性能表选择200吨汽车吊。综合考虑为了节省时间以及加快工作效率,因此决定只用1台300吨吊车,(需用的200吨吊车由300吨吊车替代,取费按200吨结算。3.4吊车机具选择 根据以上计算结果及吊车性能表选择300吨轮式起重机(全配重)3.5吊车索具选择 单根绳索受力S=Q计/(n*sin)=k1k2(Q+q)/(n*sin) =22.4/(8*sin45)=3.95 查表选择安全系数为5,得出绳索最小破断拉力: 3.95*5=19.75T 其中n-吊车绳索分支数,为4 -绳扣与水平方向夹角用途安全系数用途安全系数做缆风绳3.5作吊索无弯曲时6-
21、7用于手动其中4.5作捆绑吊索8-10用于机械起重5-6用于载人升降机14 查五金手册或起重机械安全技术检验手册应选择吊装用27(6*37+1-27-270KN)钢丝绳。 3.6施工机具布置300吨吊车站位在主厂房南侧和北侧东面,设备运输路线为原煤厂到扩建主厂房吊车旁边适合处,警戒区域为以吊车中心位置周围50米,吊车型号为300吨汽车吊,作业半径最大为33米。吊车时指挥人员站在一层平面位置及三层(+9。5m)位置,四层(+16.5m)位置,吊车伸臂最高高度36.6m。3.7吊装过程 本次吊装特点是漏斗及筛子尺寸较大、质量较重,难点在于吊车站位较远,设备所在平面处回转半径大,必须保证漏斗及筛体的
22、角度及水平,以实现吊装工作的安全性和顺利性,吊车步骤:先吊装厂房南侧2台较小的漏斗及筛子,首先用两台25吨吊车将漏斗及筛子稳定放于20吨的板车上,然后吊车去现场就位,车头方向位于正东,吊臂面向板车设备方向,角度与吊车所在平面成45 ,进行试吊,确认无误后,在进行吊装。在吊装前提前在漏斗及筛子合适位置处设两根防风绳,保证漏斗及筛子在吊装过程中不会出现较大的摆动和便于调整方向角度。南侧吊装完毕后再将吊车移入厂房的北侧东面,吊装过程同上。4. 技术措施设备基础及支座已安装检查完毕,允许偏差:水平度:2/1000;对角线偏差:1/1000;相对标高差:2mm;5.安全措施1. 基本安全操作(1) 穿绳
23、:确定吊物中心,选好挂绳位置;穿绳应用铁钩,不得将手臂伸到吊物下面;吊运棱角或易滑的吊物,必须加衬垫、有套索。质量的重要性,提高施工人员施工质量的自觉性。(2)挂绳:应按顺序挂绳,吊绳不得相互挤压,、交叉、扭压、绞拧;一般吊物可用吊挂法,必须保持吊物平衡;对于易滚、易滑或超长货物, 宜采用索绳方法,是用卡环锁紧吊绳。(3)试吊:吊绳套挂牢固,起重机缓缓起升,将吊绳绷紧稍停,起升不得过高;试吊中,信号工,挂钩工、司机必须协调配合,如发现吊物重心偏移或与其他物件粘连等情况时,必须立即停止起吊,采取措施并确认安全后方可起吊。(4)摘绳:落绳、停稳支撑后方可放松吊绳;对易滚、易滑、易散的吊物摘绳要用安
24、全钩挂钩工不得站在吊物上面;如遇不易人工摘绳时,应选用其他机具辅助,严禁攀登吊物及绳索。(5)抽绳:吊钩应于吊物中心保持垂直,缓慢起绳,不得斜拉,强拉,调运易损、易滚、易倒的吊物不得使用起重机抽绳。(6)吊挂作业应符合下列要求:索绳吊挂应便于摘绳操作。卡具吊装时应避免卡具在吊装中被碰撞。扁担吊挂时,吊点应对称于吊物重心兜绳吊挂应保持吊点位置准确、兜绳不偏移、吊物平衡(7)新起重工具、吊具应按说明书检验,经试吊无误后方可正式使用。不允许起吊的情况:准备工作没有按方案要求完善;没有对所有相关人员进行技术交底,五级以上大风、雷雨、下雪、低温等恶劣天气状况;风力在四级以上时不得吊运兜风大件等。6、成品
25、保护6.1大件设备水平运输时,严禁设备直接与地面接触,所用道木的支撑点必须在梁上,且不得超过梁的承载力。6.2施工中,在楼板上打孔必须经甲方同意,并不能破坏主筋。未安装设备的保护6.3设备运输过程中,必须绑扎牢固,运输车辆不得超吨位运输,运输道路必须平整,坚固。6.4设备存放:短期存放的设备,必须有防雨措施,设专人看管。长期存放的设备,应放在库房内。6.5设备吊装:设备吊装时根据说明书的要求,选择合适的吊装点,切忌在设备上乱割,乱焊吊装点。6.6已就位设备,施工中严禁乱焊和电焊起弧,设备不能当做地线使用。6.7设备上不放置杂物,保持清洁。6.8设专人负责,专人看护,专人保养。6.9恶劣环境下的
26、设备,应采取包裹和防潮措施。附件1 主要危害点预测和防范措施序号作业项目可能出现的事故反事故措施负责人一设备吊装起重机械倾翻、折臂的危险核实重量,严禁超载技术员、起重工确保吊机站位地面有 足够的耐压强度吊机手吊装方案必须经审批技术员作业时动作平缓,避免冲击吊机手设备起吊坠落的危险吊耳的设置及各受力构件应经过验算,确保有足够的强度技术员所有起重设备、索具必须经检查合格方可投入使用起重班长作业人员高出坠落的危险高空作业人员必须经体检合格,登高前必须系好安全带或速差保护器作业人员按规范规定挂设安全网、安全绳临时平台按规定搭设防护栏杆物体打击的危险进入施工现场必须正确佩戴安全帽作业人员高空作业工具、螺
27、栓、焊条等应备好工具袋和保险绳杜绝立体交叉作业安装班班长、安监员高空作业区域设醒目的警戒牌标志,无关人员禁止入内安监员雨季施工作业人员滑倒的危险高空作业人员必须穿软底防滑鞋作业人员高空操作、行走时,预先挂设安全绳200吨汽车吊车LTM1300/1-300t全液压汽车吊机LTM1300/1-300t全液压汽车吊机主臂额定性能表:支腿开距=8.858.5m、旋转角度=360、标准配重=87.5t以下工况仅供参考,实际请与本公司业务员联系!回转半径(m)1520.225.430.535.740.946.151.256.46033.530020120018515244.5131120120112116
28、110114111959376561131001049210592104929188756960594978898082738273827381726464575748453938.53291072616559655965596558645956544340.536.53531.530.525.525.412145449.55348.553485449.55148383633.532.529.828.524.924.5161842 413540.53642.536.5423631.528.328.9262623.62321.4202230.5 3228.331.527.93127.225.82
29、3.523.42121.519.619.618.1242625.1 24.722.124.121.421.820.419.217.617.916.416.715.4283019.8 19.117.119.217.716.315.115.113.914.313.232341613.31614.51413.212.811.812.211.3363813.211.312.411.711.210.610.59.8404211.210.2109.49.18.744468.98.58.37.948507.57.152545658伸1缩2工3况4()00/00/0/046/0/046/0/092/46/09
30、2/4692/4692100046/046/0/046/0/046/46/046/92/9292/92/9292/929210000/00/46/046/46/9246/46/4646/46/9246/92/9292/929210000/460/46/920/46/460/46/4646/46/4646/46/9246/929210000/0/460/46/920/0/460/0/460/46/9246/46/9246/46/9246/46/92100to 52nd of the Ordinance, to violate the partys solidarity and unity, su
31、ch as punishment of violations of political discipline as specified. The 52nd new missions Gang gang, clique, cliques within the party, cultivating private power interests or by Exchange, creating a momentum for their activities, such as fishing for political capital, punishment imposed serious warn
32、ings or withdrawal of party posts in serious cases, punishment imposed or placed on probation within the expelled. (3) on the rival groups review provisions of the party Constitution, must comply with the obligations of the party faithful are party members. Party members must obey decided shall not
33、contravene the Organization decided to have problems to find organizations, relying on the Organization, a deception organization, against the organization. For example . Female country (territory) outside, such as employment, income, property and investment matters, for failing to report, not truth
34、fully report, undeclared, and so on, depending on the seriousness, give criticism and education, within a time limit, shall be ordered to make checks and commands his conversation, criticized or adjustment of status, removal and so on, constitutes a disciplinary offence, disciplinary action in accor
35、dance with the relevant provisions. But since the original was not appropriate in the specific provisions of the regulations, for violations of the provisions do not report, report the matters related to the personal behavior does not correspond to the discipline of sanction, in practice it is diffi
36、cult to operate. On this, for solution not report, and not truthfully report personal about matters 15 asked blamed of problem, new Ordinance increased has 67th article, on violation personal about matters report provides, not report, and not truthfully report of behavior proposed has clear of dispo
37、sition according to, makes this class disciplinary behavior no longer has empty can drill, for carried out personal about matters checks verified, and cadres supervision, and discipline review, work provides has powerful of discipline guarantees. (2) with regard to illegal organizations, will partic
38、ipate in the fellow and alumni, to comrades 68th of the regulations provides that the party cadres violating relevant regulations, participation in spontaneous fellow, alumni, friends, etc, to be punished according to the seriousness of it. Of particular note here is three things: first, this articl
39、e is merely cadres, reflects the high requirements for leading party cadres; the other is in violation of the 2002 Central Commission for discipline inspection, the Central Organization Department and the general political Department jointly issued the circular on leading cadres should not participa
40、te in the voluntary establishment of villagers and alumni and ally organization notice of the relevant provisions. That is organized, villagers participating in the established clubs, alumni, comrades will constitute a disciplinary offence is contrary to the premise of this rule. Specified in the no
41、tice, leading cadres should not participate in the ups compatriot, alumni, various organizations such as the association between comrades, sponsors and organizers of the exclusion of such association shall in such association in corresponding positions; not the opportunity to weave network, Pro-close drain, Gang gang, but not the Alliance, Jin LAN sworn, and so on. Third, there no organization was established with the participation of fellow clubs, alumni, and friends. Breaking第 15 页 共 13 页
链接地址:https://www.31doc.com/p-2126569.html