长大上坡路段沥青路面抗车辙技术研究.pdf.doc.doc
《长大上坡路段沥青路面抗车辙技术研究.pdf.doc.doc》由会员分享,可在线阅读,更多相关《长大上坡路段沥青路面抗车辙技术研究.pdf.doc.doc(152页珍藏版)》请在三一文库上搜索。
1、 分类号:U41;U210710-B2007123博 士 学 位 论 文长大上坡路段沥青路面抗车辙技术研究李 江导师姓名职称申请学位级别郝培文 教授学科专业名博士道路与铁道工程论文提交日期 2013年11月1日 论文答辩 2014年4月16日学位授予单位长安大学 Study on the Anti-rutting Technology for UphillSections of Long and Large Longitudinal Slope ofAsphalt PavementA Dissertation Submitted for the Degree of DoctorCandidat
2、e:Li JiangSupervisor:Prof. Hao PeiwenChangan University, Xian, China 摘要交通荷载作用于长大上坡路段沥青路面的状况与平坡路段相比,其对沥青路面的作用时间变长,在重载、高温的综合作用下,长大上坡段沥青路面的车辙变形发展、形成速度更快。系统开展长大上坡路段沥青路面抗车辙技术研究,对有效控制和解决长大上坡路段沥青路面的车辙问题是非常必要的。本文通过实地调查分析了长大上坡路段沥青路面的车辙病害、路面结构内温度分布状况、重载货车运行速度变化状况,结果表明:(1)车辙、推移病害是长大上坡路段沥青路面的主要病害类型,在夏季高温、重载、低速车
3、辆荷载综合作用下,可能在夏季温度最高的一周或两周内快速形成车辙,通常连续上坡一侧的车辙深度是其他路段的 23倍;(2)长大上坡路段沥青路面车辙变形主要发生在中面层,其次是表面层、下面层;(3)沥青路面结构内的最高温度超过了 60。(4)在较长的长大上坡路段,重载货车速度在下降后一直维持在 2030Km/h直至坡顶。以此为基础,提出了以满载货车车速作为定义长大上坡路段的指标。利用有限元数值计算法,分析了高温、坡度(水平分力)、车速、重载对长大上坡路段沥青路面应力的影响,结果表明:随着车速的降低,沥青路面应力有较大增长,坡度虽对长大上坡路段沥青路面受力状况的影响较小,但会导致重载车辆车速降低从而产
4、生车辙变形。采用可变速荷载轮新型车辙仪模拟了重载车辆速度变化对沥青路面车辙的影响,不同轮速、温度、荷载条件下的车辙试验结果表明:在重载、高温、低速荷载条件下,以标准车辙试验条件设计的沥青混合料容易形成车辙,采用现行技术规范规定的 60温度条件评价长大上坡路段沥青混合料高温稳定性不尽合理。采用多级嵌挤密级配设计方法和 Superpave方法进行沥青混合料配合比设计,通过汉堡车辙试验和 MMLS3 加速加载试验研究了不同沥青(含外掺剂)、不同混合料类型在不同荷载与温度条件下的抗车辙性能,推荐了适用于长大上坡路段的沥青混合料类型及其技术要求。在现场调查和对长大上坡路段沥青路面受力特点分析的基础上,明
5、确了上、中面层是沥青路面产生车辙变形的主要层位。在加速加载试验验证路面结构合理组合及厚度基础上,提出了适用于长大上坡路段的沥青路面结构组合。最后,基于交通管理技术措施,提出了采用夏季高温时段洒水降温、设置专用爬坡I 车道、调整车道系数和重载车辆分时段通行等技术措施来减轻长大上坡路段沥青路面车辙。关键词:长大上坡,纵坡,低速荷载,车辙,路面结构组合,洒水降温II Abstract Compared with flat slope sections of asphalt pavement, the action time that low-speedvehicle load to uphill s
6、ections of long and large longitudinal slope is much longer, in thecondition of comprehensive combination of heavy load and high temperature, the rutting onuphill sections of long and large longitudinal slope has faster speed of development andformation.Carrying on the comprehensive research on the
7、anti-rutting of asphalt pavement withuphill sections of long and large longitudinal slope, which is necessary for solving andeffectively control the rutting problem.The results of field survey show that: (1) the rutting and push is main types of pavementdistress with uphill sections of long and larg
8、e longitudinal slope, which develop easily thatprobably rapid forming in the highest temperature of the summer for one or two weeks. underthe high temperature, combined with heavy load and low speed load, usually the rutting depthin the uphill sections of long and large longitudinal slope is 23 time
9、s than other sections. (2)the deepest rutting lies in middle layer, the second lies in surface layer. (3) The highesttemperature is over 60 in the asphalt pavement structure.(4) Overloaded truck speed afterthe fall on uphill sections of long and large longitudinal slope has maintained at 20 30 km/hu
10、ntil the uphill sections top.On the basis of rutting occurrence of uphill sections of long and large longitudinal slopeand the statistics of truck speed, this paper argues that the speed of full truck as thedefinition indicator for uphill sections of long and large longitudinal .With the finite elem
11、ent modeling calculation, analysis the mechanical response andrutting formation mechanism of uphill sections of long and large longitudinal slopecomprehensively, analysis the influence of gradient (component), speed of vehicle, overloadto uphill sections of long and large longitudinal slope of aspha
12、lt pavement, it shows that thestress of asphalt pavement has bigger growth with the lower speed, growth effects to stresscondition for the slope itself is smaller, but the slope effect on the rutting mainly leads to thedecrease of heavy vehicle speed resulting in increase of effect time of vehicle l
13、oad and asphaltpavement.It adopts the new rutting test equipments that the load and wheel speed can be changed tosimulate the influence of overload vehicles speed change(loading time) on the rutting, theresults show that the load size, loading time and temperature have an equivalent effect. AndIII t
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 长大 上坡 路段 沥青路面 车辙 技术研究 pdf doc
链接地址:https://www.31doc.com/p-2214278.html