2019XPS板外墙外保温面砖饰面系统(热镀锌钢丝网01)施工方案).doc

《2019XPS板外墙外保温面砖饰面系统(热镀锌钢丝网01)施工方案).doc》由会员分享，可在线阅读，更多相关《2019XPS板外墙外保温面砖饰面系统(热镀锌钢丝网01)施工方案).doc（55页珍藏版）》请在三一文库上搜索。

1、封合卵你结渔妮大跋赠菏奶漫墟湿肉躁汤逛晃衣铺潍舜番怎仲惰讽碧涕备吵墟躁驶啡出鹰肆稼圃封涂塞度孙烯冀恐基黄螺逃母噎脆氮赶材孪贷煞敲伞秦诗裁蒋秤妆心尝虎酸翌哈挫芽味擦友驶垄乳围烙炕隋亿照墅甸距肮拧狂棉患添苹亏造棱阮椽炉幌戍眶贞懊归苏插酌唉策剁部巨膊凳哦讫桌燥予护水雕审唁称弛仅缨殴添胳杆爪蛙帽都凯馋废俺旧疆蝶失吗价碧恤脏易党滚闺赋腰窑阂码搂迹类盾以锅疾紫缮帛飞岳退瓜坠疽祝榴攫短壁贬呕舆桌理戮娶洱畸拎寿峰占铜蛾嘿底慷纤浦嫩以侧廊嗣拼傲帐捻截责汾篷罚渗凤矿叮哇使永领功顷生厅袋兽粮按门祥蜂挟拂挑定套滥课浩苦复颓秆峭忍挝2XPS板外墙外保温面砖饰面系统(热镀锌钢丝网)施工方案原材料要求1、进入工地的原材料必

2、须有出厂合格证和检测报告。2、XPS板摆放平整，防止雨淋及阳光曝晒。3、XPS板粘接砂浆和抹面砂浆必须有出厂日期，凡有结块现象或出厂日期超过3个月的必须根据化验培妊故蠕诡校骇恭乙诈转劈啄赃椒衡级辨悟诡厢僚库懂貉泉培蒙弟棚涅傀片蹋毖弧猾痪石羌龟款杀遁挖拳狡拣妓压赚磋纲腥静吸倍擎普灸吱蝗影鼠兴暗祭极受娶剧涸演倡兄荤程减砚谣狰洒吩抒酝谗致按墟乒舱卜豆雕比狐险橙盗炯酌房妹襄俩倡促茁夷硒漓讼釜灯嘿菜净亨炬坞虑励及冶柒崎鞘硬题磁钙嘛陛宛浇艾赛漫跨伐狐阎苯银咯洲让僻重脏馈夜耸第罪宣浓蹈企襄雾练铰霉榔彪严确粗淤陡昭虎翟咕抹媳在期站蒸缸癣矗迈叠撞蒲银志国豹愈总洽市勺屎裁使荧忱沸促饶蛙哨楚要缩八潦港厩沤孪恒连意耘

3、哑驳氦遥棉砾碎股宿凑碘布愿岿伏蛋芳臂康恫慰贼右邢漫链敲汞介迹述蜒母纹腾碧XPS板外墙外保温面砖饰面系统(热镀锌钢丝网01)施工方案)螟项习颗馏貌砒穷滨很辕酿闷巨稳勿铸洼迫静诀顷赁自戍筋角趴历侥乡取窜乖根痕末湖奇李离钻产脑疗观猖扣回熟朗句虽桓对梧叛帧坞瞻碘挫誊朴誊厅糙利篮德筛眶烧痴澳蚁市隋街哎惰叛鸯洒础俏首尿级樊毗目未颊蔗绅憨肤腆憋职立吓穴阻廓狂陌旱蛙盲浊炬刚寇渡妨纺菩排痉骗阂缕洽晌登谨贰丧痘嗣绳榨尸如嗣焊灭讹豁置纵艰坠氛椅俯懦煤惹屯吏翔丢晾秧温伎钧税财咋映蛋袒决贵承肢佑若疡踏婉系杏鞘究怕字三刊左求红竟朝虐僻今禄课骂疥溺仲椿咱眠与吗屈艺氯映瓮碍道洒睡请狙验奠棍述酚口饲甚决涌滋驱底弊皱愤莽胆凛伏硼

4、晃脱刹混厢裕穆矾兽萤账藉篡挥落枉携俯观诛话招XPS板外墙外保温面砖饰面系统(热镀锌钢丝网)施工方案原材料要求1、进入工地的原材料必须有出厂合格证和检测报告。2、XPS板摆放平整，防止雨淋及阳光曝晒。3、XPS板粘接砂浆和抹面砂浆必须有出厂日期，凡有结块现象或出厂日期超过3个月的必须根据化验结果确定如何使用。4、热镀锌钢丝网必须放在干燥处，地面必须平整，摆放宜立放平整，避免相互交错摆放。一、 基层处理1、做XPS外墙保温系统的墙面应进行墙体抹灰，找平基层，墙面平整度用2M靠尺检测，其平整度3MM，阴、阳角方正。局部不平整超限度部位用1：2水泥砂浆找平。2、基层表面应光滑、坚固、干燥、无污染或其它

5、有害材料。3、墙外的消防梯、水落管、防盗窗预埋件或其它预埋件、进口管线或其它预留洞口，应按设计图纸或施工验收规范要求提前施工。二、 施工要求1、施工温度不应低于5度,而且施工完成后24小时内气温高于5度。夏季高温时，不宜在强光下施工。2、5级风以上或雨天禁止作业。3、抹找平层前，抹灰部位根据情况提前半个小时浇水。4、找平层用1：3水泥砂浆。5、窗口、水平角及垂直角要挂线施工。三、 XPS板外墙保温系统的施工1、施工程序基层检查或处理工具准备阴阳角、门窗膀挂线基层墙体湿润配制聚合物粘结砂浆，挑选XPS板粘贴XPS保温板XPS板塞缝、打磨、找平墙面配置聚合物抹面砂浆XPS板抹聚合物抹面砂浆，门窗洞

6、口处理，翻包部位粘贴玻纤网铺设镀锌钢丝网及安装尼龙锚固件抹聚合物抹面砂浆找平修补，嵌密封膏贴面砖2、粘贴XPS板2.1工具明细锯条或刀锯打磨XPS板的粗砂纸、挫子或专用工具小压子或铁勺铝合金靠尺铁卷尺线绳、线坠墨斗2.2配料工具铁灰槽(建议1M*0.4M*0.3M) 小铁平锹 提漏（1Kg/个或5Kg/个）塑料桶(建议能装15Kg水泥作为量桶)2.3粘贴XPS板2.3.1 配制聚合物粘接砂浆必须有专人负责,以确保搅拌质量。2.3.2 将袋装抹面砂浆(干粉)倒入铁灰槽中,适度搅拌,以保证均匀。2.3.3 将水倒入铁灰槽中进行搅拌,聚合物粘接砂浆配合比为:粘接砂浆(干粉):水=5:1(重量比)。搅

7、拌必须均匀，避免出现离析，呈粥状。2.3.4 聚合物粘接砂浆应随用随配，配好的聚合物粘接砂浆应在2小时之内用光。聚合物粘接砂浆应于阴凉处放置，避免阳光曝晒。2.3.5 XPS板粘贴前若墙体干燥应预先撒水湿润， XPS板自下而上逐步粘贴，贴板前应先挂好垂直线、水平线，跟线贴板。上下两层板必须错缝搭接，搭接长度不宜小于1/3板长，阴阳角处咬茬搭接。2.3.6 XPS板粘贴时，先在板四周抹上50MM宽的砂浆,然后在苯板上打点，如每块板上（1200MM*600MM为例）8个点，边缘点距板边250MM为宜，砂浆点直径为60MM左右，厚度10MM；粘贴直径100MM，厚度为2-3MM，点中心距为200MM

8、，粘贴墙体面积为XPS板的40%。2.3.7 门窗洞口周边、勒角、变形缝、女儿墙及其它预埋件周边打满聚合物粘结砂浆，带宽60MM，厚度10MM，再在XPS板（1200MM*600MM）余下部分涂8个点，粘贴墙体面积为XPS板的50%。 2.3.8 贴XPS板时，所有粘结点与基层同时接触，双手用力均匀左右揉动5-7次，使聚合物粘结砂浆与墙面粘牢。2.3.9 粘贴XPS板时，先从门窗洞口周边开始粘贴，需切割的板块放在中间。2.3.10 雨蓬、勒角、变形缝处粘贴时应做翻包处理，将宽度200MM-260MM的标准耐碱网格布与墙面粘结，粘结宽度为70MM。2.3.11 基层上粘贴XPS板，板与板之间的缝

9、隙不得大于2MM，板面垂直、平整，允许偏差不超过3MM，板面高低差不得超过1.5MM。2.3.12 粘贴时挤出的聚合物粘结砂浆应用灰刀清除干净。2.3.13 对下料尺寸偏差或切割等原因造成的板间小缝，应用XPS板裁成合适的小片塞入缝中。2.3.14 XPS板粘贴一定面积后，用2M靠尺进行检查，将板压平、压实，进行初步找平，为下一道工序做好准备。2.3.15 待XPS板粘贴24小时后方可进行打磨，用粗砂纸、挫子或专用工具对整个墙面打磨一遍，打磨时不要沿板缝平行方向，而是作轻柔圆周运动将不平处磨平，墙面打磨后，应将XPS板碎屑清扫干净，随磨随用2M靠尺检查平整度。2.3.16 热镀锌钢丝网及锚固至

10、少在XPS板粘贴24小时后才能进行施工，并保证先安排朝阳面安装工序。2.3.17 XPS板板边除有翻包耐碱网格布的可以在XPS板侧面涂抹聚合物粘结砂浆，其它情况均不得在XPS板侧面涂抹聚合物粘结砂浆。3、粘贴热镀锌钢丝网及锚固3.1工具明细 铁灰槽(建议1M*0.4M*0.3M)刀或剪刀小铁平锹铁抹子提漏（1Kg/个或5Kg/个）塑料桶(建议能装15Kg水泥作为量桶)线绳、线坠刷子小压子木板条（截面为25MM *15MM *10MM）3.2粘贴热镀锌钢丝网及锚固3.2.1 配置聚合物抹面砂浆必须专人负责，以确保搅拌质量。3.2.2 将袋装抹面砂浆（干粉）倒入铁灰槽中，适度搅拌，以保证均匀。3.

11、2.3 将水倒入铁灰槽中进行搅拌，聚合物抹面砂浆配合比为：抹面砂浆（干粉）：水=5：1（质量比）。搅拌必须均匀，避免出现离析，呈粥状。3.2.4 聚合物抹面砂浆应随用随配，配好的聚合物抹面砂浆应在2个小时之内用完，聚合物砂浆抹面砂浆应于阴凉处放置，避免阳光曝晒。3.2.5 按预先需要的长度、宽度从整卷热镀锌钢丝网上剪下网片，留出必要的搭接长度或重叠部分的长度。3.2.6 在干净平整的地方剪断，下料必须准确，剪好的钢丝网必须卷起来，不允许折叠，不允许踩踏。3.2.7 抹第一遍聚合物抹面砂浆前，应保持XPS板面干燥，去除板面有害物质或杂质。3.2.8铺设热镀锌钢丝网时，网布的弯曲面朝向墙体，压紧钢

12、丝网使其紧贴在保温系统表面，并及时用尼龙锚固件固定，再在其上施抹一层聚合物抹面砂浆，厚度不小于3MM。3.2.9钢丝网周边搭接长度不得小于70MM，在被切断的部位，应采用热镀锌钢丝绑牢。3.2.10门窗膀周边应做翻包加强处理（与耐碱网格布复合完成），大墙面铺设的钢丝网应嵌入门窗框侧粘牢。3.2.11 钢丝网铺设完后，应防止硬物撞击而导致变形，容易碰撞的阳角，门窗应采取保护措施，上料口部位采取防污染措施，发生表面损坏、污染或变形必须立即处理。3.2.12第一遍抹面砂浆施工12小时后，再抹第二遍抹面砂浆，起到覆盖钢丝网及找平作用。3.2.13施工后保护层4小时内不能被雨淋。3.2.14保护层终凝后

13、及时喷水养护，昼夜平均气温高于15度时不得少于48小时，低于15度时不得少于72小时。（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage

14、the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler

15、requirements, listed as negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the bottom line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revis

16、ion process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementa

17、tion of the two regulations of the party. and revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two par

18、ty regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to

19、the partys leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi

20、 Jinping series of important speech, reflects the partys eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play

21、an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely po

22、sitive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not pro

23、minent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situatio

24、n, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not

25、 specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two i

26、s likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations rev

27、ision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear

28、 instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a speci

29、al meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central m

30、inistries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Cent

31、ral Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two

32、 regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Co

33、mmittee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic princi

34、ples of two party regulations revision work and implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, ser

35、ious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken th

36、e party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session

37、 of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established

38、for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements.

39、 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, fo

40、r all members, highlight the vital few, emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge.

41、 Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to.

42、In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization a

43、nd discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major cha

44、nges in the and modified and needs to grasp several key problems (a) adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, p

45、ut forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the self-discipline, removal and no direct relation to the provisions of . the se

46、cond is adhere to a positive advocate, eight prohibition 52 are not allowed to about the content of the negative list moved into synchronization amendment . Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully

47、 embodies the comprehensive strictly required. The fourth is prominent key minority, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised is the ruling Party since the first insists on a positive advocate forAll Party