压缩空气管道清洁吹哨方案.pdf
《压缩空气管道清洁吹哨方案.pdf》由会员分享,可在线阅读,更多相关《压缩空气管道清洁吹哨方案.pdf(9页珍藏版)》请在三一文库上搜索。
1、 COR Project Jiang Co RNING Name: Corning D gsu Nantong N orning D CD Display Technolo NO.2 Constru Display 康宁康宁显显 DA PIP 压压 Est 编制 Re 审核 Ap 批准 Da 日期 CDA PIPE ogies (China) Co ction Group y Techno 显显示科示科技技 PE CLE 压压缩空缩空气气 tablishmen 制 view 核 prove 准 te 期 CLEANING o., Ltd Phase II ologies 技技(中(中国国 EA
2、NING 气气管道管道清清 (REV.1) nt 20 G PROCEDU Title: ME (China) 国国)二)二期期 G PROC 清清洁方洁方案案 左章友 011731 URE EPICUP&OSBL )Co.Ltd 期期项目项目 CEDUR 案案 FL RFP No.: A6M page 1 Phase RE LUOR MW40K260 of 9 COR Project Jiang 1. CDA conta mate and CDA系 机、 可能 Ther 因此 This valve 本程 2. E GB5 工 PDD K260 3、P Flow CDA RNING Name:
3、 Corning D gsu Nantong N Purpose 目目的的 A system, inclu amination bef erials such as dirt, which if n 系统,包括其所 无机材料,如油 能会导致产品纯 refore, the pur 此,这个程序的目 cleaning proc e and other re 程序这将适用于 Executive stan 50235-97 Code 工业金属管道工 D of K260, des 0 包定义文件, Procedure an w chart CDA pi A管道清洁程序 Display Technolo
4、NO.2 Constru 的的 uding its all co fore fill with air oils, grease, p not removed, c 所有部件和零部 油,油脂、纸张 纯度受影响。 rpose of this p 目的是要控制、 cedure shall a elevant access 于K260所有CDA清 ndard 执行规执行规范范 e for construc 工程施工及验收 sign drawing o 图纸,技术参 d execution程程 ipe cleaning p 序流程图 CDA PIPE ogies (China) Co ction Gr
5、oup CDA PIPE C 压缩压缩空空 omponents an r. Harmful con paper, fiber, ra could result in 部件,在引入空气 张、纤维、破布 procedure is to 验证和记录C pply to all CDA sories. 清洁,包括零件 范范 tion and accep 收规范 or specification 参数表,或更高 程程序和执行序和执行 process CLEANING o., Ltd Phase II CLEANING P 空空气管道清气管道清洁洁 nd parts, must ntaminations w
6、 ags, wood pie unacceptable 气运行之前,必 布、木块、煤粉 o controlling, v CDA清洗工作。 A piping syste 件,法兰、阀门 ptance of indu n. Highest stan 高级别标准规范 G PROCEDU Title: ME PROCEDURE 洁洁程序程序 be adequately would include b ces, coal dust e product purit 必须充分清除有 粉、溶剂、焊渣 verifying and re em in K260 co 等其他相关配 ustrial metallic
7、 ndard must be 范。 URE EPICUP&OSBL E y cleaned to r both organic a t, solvents, we ty. 有害污染物。有 渣、铁锈、沙子 ecord CDA pip ntractor, inclu 件。 c piping e comply. FL RFP No.: A6M page 2 remove harmfu and inorganic eld slag, rust, s 有害的污染物包 子和污垢,如不拆 pe cleaning w ding fitting,fla LUOR MW40K260 of 9 ul sand 包括
8、有 拆除, orks. nge, COR Project Jiang RNING Name: Corning D gsu Nantong N Pr Display Technolo NO.2 Constru re-fabrication Shop 预制场预制场 Construc 现现场场 Ho 停 Ho 停 Transp 运运输输 CDA PIPE ogies (China) Co ction Group 管 ction Site 场场 old Point 1 停监点1 old Point 2 停监点2 port 输输 CLEANING o., Ltd Phase II Incoming Ma
9、terial Inspe 来料检查 Flush by air,cleanin 空吹、清洁 Precast 预制 Flush by air,cleanin 空吹、清洁 Seal of Piping End 管端密封 Solvent cleaning 溶剂清洗 Pipe installation (Fitting,Fixing&Weld 管道安装(装配、固定 接) Drying 干燥 Transport protectio 运输保护 Work completed 完成工作 Remove seal 去除密封 Flush by air,cleanin 空吹、清洁 G PROCEDU Title: ME
10、 ection ng ng ds ding) 定、焊 on ng URE EPICUP&OSBL FL RFP No.: A6M page 3 LUOR MW40K260 of 9 COR Project Jiang 4. O 4.1. I Inspe dust purit 主要 渣、 4.2 The air fo 管子 空气 Prio pipin 吹扫 Tec 向参 Pri injure 吹扫 4. 3 Prefa 管道 4. 4 The blow oil fre 管子 移动 4.5 S RNING Name: Corning D gsu Nantong N peration proc In
11、spection of ection the clea , solvents, we y. 要检查CDA管道清 铁锈、沙子和 Flush by air e pipes, fitting or the pipe cle 子、管件和其他 气。 or to blowing, ng system can 前,经对系统 chnical orienta 参加吹扫工作的 or to blowing, e. 开始前,应通 Pre-Fabrica ab the CDA pi 道预制根据管道 Cleaning pi e pipes, fitting w the prefab pi ee compresso 子、管
12、件和其他 式无油压缩机 Solvent clean Display Technolo NO.2 Constru cedure & tech f system befo an status of th ld slag, rust, s 清洁情况,包括 和污垢 r, cleaning 空空 s and other co aning and pur 他组成件先人工 piping system n be commenc 统的实体及资料 ation will be m 的人员进行技术 , notify releva 通知排出口周围 ation pipe 预预 ipe according 道预制图纸和相
13、ipe after Pre- s and other co pe, in order ors will be use 他组成件先用手 机来进行压缩空 ning 溶剂清溶剂清洁洁 CDA PIPE ogies (China) Co ction Group hnical require ore blowing来来 he CDA pipe ,s sand and dirt, 括有机、无机材 空空吹、清洁吹、清洁 omponents wi rging, tempora 工清洁, 为了有 m should be ch ced. 料进行全面检查 ade to the per 术交底。 nt personn
14、el t 围工作的人员离 制管道制管道 the pipe prefa 相关国标进行。 Fabrication 预预 omponents wi r to have suffic ed to filled up t 手擦拭干净, 然 空气。 洁 洁 CLEANING o., Ltd Phase II ement操作程操作程序序 来来料检查料检查 such as oils, g which if not re 材料,如油,油脂 ll be clean by ary mobile oil f 有充足的空气来 hecked out, On 查,确认合格后 rsonnel who a that work
15、arou 离开危险区,防 ab drawings b 预预制后的管道制后的管道 ll be clean by cient air for the the CDA stora 然后再用压缩空 G PROCEDU Title: ME 序序及技术要求及技术要求 grease, paper, emoved, could 脂、纸张、纤维 hand firstly. T free compress 来清洁管子,采 nly accepted o 后方可进行。 attend blowing und the vent a 防止人身安全事 y approved an 清洁清洁 hand swabbin e pip
16、e cleaning age tanks 空气清扫,为了 URE EPICUP&OSBL , fiber, rags, w d result in una 维、破布、木块 Then, in order sors will be us 采用移动式无油 of piping syste work. air to be off to 事故。 nd reference G ng firstly. Then g and purging 了有充足的空气 FL RFP No.: A6M page 4 wood pieces, c cceptable pro 块、煤粉、溶剂 to have suffic sed
17、 . 油压缩机来进行 em then blowin o avoid accide GB code n,use the pres g, temporary m 气来清洁管子, LUOR MW40K260 of 9 coal duct 剂、焊 cient 行压缩 ng for ent of ss air mobile 采用 COR Project Jiang The Use conta 清洗 The befo 溶剂 Pipe 清洁 4.6 D Oil 无油 4.7 T Direc 目视 Ultr may 许多 SB Ultra hydr SB-IO The by th 如果 Inspe 检查 4.
18、7 S Pro RNING Name: Corning D gsu Nantong N pipe after blow e acetone solu ainers sizes w 洗剂采用丙酮溶 e solvent clean re the cleanin 剂清洁管子、管 e be cleaned s 洁管道内无粉尘 Dry the pipe 干干 free air will be 空气可用来进 Testing 检测检测 ct visual inspe 视检测(紫外线 raviolet light c not otherwise 常见的烃类或 -IOOP-IOOW aviolet inspec
19、t rocarbon fluore OOP-IOOW紫 e item being e his inspection 果检测出来外表 ection check s 查清单要提交( Seal 密封密封 otection from r Display Technolo NO.2 Constru w clean need ution Cleaner, will be producte 溶剂清洁,清洁 ned pipes, fitti g solution drie 管件和其他组成 hould not con 尘颗粒、油脂等 干干燥 燥 e used to blow 进行管道干燥。 ection (Ul
20、travio 线) causes many c e be detectable 或有机油或油脂 Ultraviolet lam ion should ind escence. 外线灯,将用于 examined mus method. 表有杂物的话, sheet to be iss 交给福陆) recontaminatio CDA PIPE ogies (China) Co ction Group to solvent clea , solvent which ed in site fact. 洁溶剂采用自制 ings and other es. 成件。 tain particles 等。 w
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 压缩空气 管道 清洁 方案
链接地址:https://www.31doc.com/p-3580813.html