SAE J2388-2002 Secondary Control Modifications.pdf
《SAE J2388-2002 Secondary Control Modifications.pdf》由会员分享,可在线阅读,更多相关《SAE J2388-2002 Secondary Control Modifications.pdf(14页珍藏版)》请在三一文库上搜索。
1、SAE Technical Standards Board Rules provide that: “This report is published by SAE to advance the state of technical and engineering sciences. The use of this report is entirely voluntary, and its applicability and suitability for any particular use, including any patent infringement arising therefr
2、om, is the sole responsibility of the user.” SAE reviews each technical report at least every five years at which time it may be reaffirmed, revised, or cancelled. SAE invites your written comments and suggestions. TO PLACE A DOCUMENT ORDER: +1 (724) 776-4970 FAX: +1 (724) 776-0790 SAE WEB ADDRESS h
3、ttp:/www.sae.org Copyright 2002 Society of Automotive Engineers, Inc. All rights reserved.Printed in U.S.A. SURFACE VEHICLE 400 Commonwealth Drive, Warrendale, PA 15096-0001 RECOMMENDED PRACTICE J2388 ISSUED MAR2002 Issued2002-03 Secondary Control Modifications TABLE OF CONTENTS 1.Scope. 2 1.1Purpos
4、e 2 1.2Applications 2 1.3Conditions 2 2.References. 3 2.1Applicable Documents3 2.2Related Publications. 3 3.Definitions.4 4.Technical Requirements. 5 4.1General Design Requirements. 5 4.2Extensions and Attachments 6 4.3Maintenance and Serviceability6 4.4Operations 7 4.5Labeling 7 4.6Specific Compone
5、nts and Systems 7 4.6.3Mode A Controls and Systems. 7 4.6.4Mode B Controls and Systems. 8 4.6.5Mode C Controls and Systems. 9 4.7Installation Manual . 10 4.8Owners (User) Manual. 10 4.9Warranties 11 SAE J2388 Issued MAR2002 -2- 1.ScopeThis SAE Recommended Practice establishes a uniform procedure for
6、 assuring the manufactured quality, provision for proper installation, and service performance of certain automotive products, specifically, the relocation, alteration, replacement and/or extension of secondary controls and systems. These include the following: Cruise Control; Door Locks; Gear Selec
7、tor; Hazard Flasher; Headlight Beam Selector; Heater/Vent/Air Conditioner (HVAC); Horn; Ignition/Starter; Light controls; Mirrors; Parking Brake; Power Seats; Rear Accessories (Defogger, Wiper/Washer); Turn Signals; Window Regulators; and Windshield Wiper/Washer. The purpose of any Secondary control
8、 adaptation is to provide the effective use of the motor vehicle operating systems to a driver with a disability, so that he or she may drive and operate that motor vehicle with the same degree of safety as a driver who does not have a disability. Thus, the adaptive equipment must be (1) accessible
9、to the driver with a disability for whom it is designed, (2) not susceptible to inadvertent operation which may be inconvenient or dangerous for the driver and other users of the highway transportation system, and (3) suitable for use by other drivers who may have a need to operate the motor vehicle
10、. For purpose of this document, the secondary controls listed previously have been classified according to the following protocols. The categorization of these controls, while different from other SAE publications, is reflective of the manner in which driver rehabilitation specialists determine appr
11、opriate vehicle modifications. These categories are arranged to assign priorities that allow the user to operate a vehicle in the most efficient manner possible within the highway transportation system. Mode AThese controls shall be operable by the driver while the vehicle is in operating mode. They
12、 must be accessible to the driver for which they were intended while being able to maintain control of the vehicle steering, brake and accelerator functions. Included in this group are: Cruise control “Set;” Headlight Beam Selector; Horn; Turn Signals; and, Windshield Washer/Momentary Wipe. Mode BTh
13、ese controls shall be operable by the driver while maintaining control of the vehicle brake function with the vehicle not in motion, as in the case of vehicle start-up or re-start necessitated by engine stall. Included in this group are: Gear Selector and Ignition/Starter. Mode CThese controls shall
14、 be at least operable by the driver when the vehicle is stationary, either temporarily or parked. Included in this group are: Cruise control “On” and “Off;” Door Locks; Hazard Flashers; Heater/Vent/Air Conditioner (HVAC); Light Controls; Mirrors; Parking Brake; Power Seats; Rear Accessories (Defogge
15、r, Wiper/Washer); Windshield Wiper; and Window Regulator. 1.1PurposeThe purpose of this document is to provide criteria and methods to evaluate the design, installation, operation, maintenance, and performance of Secondary Control System adaptations. 1.2ApplicationsThis document is intended for use
16、in product design and evaluation by the final manufacturers of the equipment referenced in this document. 1.3ConditionsThis document is concerned with the performance, safety, and reliability of the products referenced. SAE J2388 Issued MAR2002 -3- 2.References 2.1Applicable PublicationsThe followin
17、g publications form a part of this specification to the extent specified herein. Unless otherwise specified, the latest issue of these publications shall apply. 2.1.1SAE PUBLICATIONSAvailable from SAE, 400 Commonwealth Drive, Warrendale, PA 15096-0001. www.sae.org SAE J1139Direction-Of-Motion Stereo
18、types for Automotive Hand Controls SAE J1211Recommended Environmental Practices for Electronic Equipment Design SAE J1292Automobile, Truck, Truck-Tractor, Trailer, and Motor Coach Wiring SAE J1477Measurement of Interior Sound Levels of Light Vehicles 2.1.2FEDERAL MOTOR VEHICLE SAFETY STANDARDSTitle
19、49, Part 571Available from the Superintendent of Documents, U.S. Government Printing Office, Washington, D.C. 20402. www.nhtsa.dot.gov/cars/rules FMVSS 101Passenger Cars FMVSS102Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect- Passenger Cars, Multipurpose Passen
20、ger Vehicles, Trucks, and Buses FMVSS105Hydraulic Brake Systems-Passenger Cars, School Buses and other buses, Trucks and Multipurpose Passenger Vehicles FMVSS108Lamps, Reflective Devices, and Associated Equipment-Passenger Cars, Multipurpose Passenger Vehicles, Trucks, Buses, and Motorcycles FMVSS30
21、2Flammability of Interior Materials-Passenger Cars, Multipurpose Passenger Vehicles, Trucks, and Buses 2.1.3U.S. MILITARY STANDARDAvailable from DODSSP, Subscripton Services Desk, Building 4D, 700 Robins Avenue, Philadelphia, PA 19111-5094. MIL-STD -1472FDesign Criteria Standard, Human Engineering 2
22、.2Related PublicationsThe following list of publications is being provided for information purposes only and is not a required part of this document. 2.2.1SAE PUBLICATIONSAvailable from SAE, 400 Commonwealth Drive, Warrendale, PA 15096-0001. www.sae.org. SAE J112aElectric Windshield Wiper Switch SAE
23、 J163Low Tension Wiring and Cable Terminals and Splice Clips SAE J195Automatic Vehicle Speed ControlMotor Vehicles SAE J234Electric Windshield Washer Switch SAE J235Electric Blower Motor Switch SAE J249Mechanical Stop Lamp Switch SAE J253Headlamp Switch SAE J259Ignition Switch SAE J287Driver Hand Co
24、ntrol Reach SAE J564Headlamp Beam Switching SAE J589bTurn Signal Switch SAE J771Automotive Printed Circuits SAE J910Hazard Warning Signal Switch SAE J915Automatic TransmissionsManual Control Sequence SAEJ1138Design CriteriaDriver Hand Controls Location for Passenger Cars, Multipurpose Passenger Vehi
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- SAE J2388-2002 Secondary Control Modifications J2388 2002
链接地址:https://www.31doc.com/p-3678370.html