《ECA-535ABAE-1987.pdf》由会员分享,可在线阅读,更多相关《ECA-535ABAE-1987.pdf(22页珍藏版)》请在三一文库上搜索。
1、E I A 535ABAE 87 E 323qbOO 007VOqO 8 W a m a v) m v) I W a I DETAIL S P E C I F I CAT I O N Fixed Tantalum Capacitors With Non-Solid Electrolyte And Porous Anode Silver Case, Axial Lead, Elastomeric Seal, Polarized, Nickel Positive, Copper Negative Leads, Insulated EIA-535ABAE MAY 1987 ELECTRONIC IN
2、DUSTRIES ASSOCIATIQN ENGINEERING DEPARTMENT Copyright Electronic Components, Assemblies +,-lo%, (see Table II) (see Table III 55/125/21 +85 C (see Table II) ( see Table 11) (see Table II) (see Table II) O (No reversal + ,-20 % of voltage permitted) Copyright Electronic Components, Assemblies tep 2:
3、Lowe: category t emperatur o (-55 C) Capacitance Tangent of loss angle Impedanco ;tep 3: Rated temperatare ( + 8 5 Cl Leakage Capacitance Current 2 U r Tangent of loss ang 1 e ;tep 4: Upper category temperature (+125 C) Leakage Current 3 U c Capacitance Tangent or loss angle s-3 2.53 or use as 0- re
4、ference I value - Table 2 trot a?plicabl e Table 1 Table 2 Table 2 Table 2 Table 2 Table 2 Table 2 Copyright Electronic Components, Assemblies & Materials Association Provided by IHS under license with ECA Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/29/2007 23:49:18 MDTNo
5、 reproduction or networking permitted without license from IHS -,-,- E I A 535ABAE 87 m 3234b00 0074055 T m EIA-535ABAE QC300202/USO005 Page 12 TABLE I V (continued) Sub-group C M P a r t of sample of Sub-group C1 4.3.1 I n i t i a l measurement 4.3 Robustness of terminations 4.4 Res is tance t o so
6、ldering heat 4.4.2 Final measurements D Capacitance Test Ua Force = 10s Special aend Visual T e s t (4.3.3 Ex m i n a t ion ZIethod: Solder Batn T e s t Tb, :lethod 1A (10 +,-ls i m m e r - sion time) Visual Zxamin- ation 6 9 1 ! l o visible Samage and no leakage or e l oc-,zol*P= _ b - . No visiSle
7、 amage and no 1eakag.e of electrolyte LegiSle marking -I Jot more than 1 defective for Subgroups C U and C13 combined- Sub-group CU3 Other parr of sample 4 . 6 . 1 I n i t i a l measurement 4 . 6 Rapid change of temperature D Capacitance 9 A = Lower category tempera ture ( - 5 5 CI category BB - Upp
8、er 181 1 Copyright Electronic Components, Assemblies & Materials Association Provided by IHS under license with ECA Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/29/2007 23:49:18 MDTNo reproduction or networking permitted without license from IHS -,-,- EIA 535ABAE 87 = 3234
9、600 0074056 II H 8 TABGE I V 4.6.3 Final measurements 4.7 Vibration 4.7.2 Final measurements 4.9 Shock 4.9.2 Final measurements (Sub-group CLB - caneinued) t em-p e r a t u r 1 (+125 Cl 30 cycles Duration t = 30 minu tes Leakage current Capacitance . Tangent of loss angle Nethod of Mounting: see 1.1
10、 of this spec i f ic at ion Procedure 8 4 Frequency Range LO to 2000Hz Amplitude: 0.75 mm or acreler. ation 20g, whichever Is less severe Total Duration: 6 h Visual Examination Method of . Mounting: se 1.1 of t h i s specification Acceleration: 981 m / s / s Duration of pulse: 6 ms Rated Voltage app
11、lied Visual examination EIA-535ABAE QC3OOZOZ/USOOO5 Page 13 ,= 1.25 times Table 2 (Cf-Ci)/Ci: +,- 10% of value measured i n 4 . 6 . 1 c,= 1.15 tim,es Table 2 ! i o v i s i b l e d mage and no 1-akage of e l e c t r o l y t e JO v i s i b l e damage and no leakage of e l e c t r o l y t e Copyright E
12、lectronic Components, Assemblies & Materials Association Provided by IHS under license with ECA Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/29/2007 23:49:18 MDTNo reproduction or networking permitted without license from IHS -,-,- -_ E I A 535ABAE A? 3234600 0074057 3 - C
13、lause number and Test (see Note i l Sub-group C 1 Combined sample of specimens of Sub- groups C U and C1B 4.10 C l i m a t i c sequence 4.10.1 I n i t i a l measurement 4.10.2 Dry Heat 4.10.3 Damp heat, cyclic, test Db, f i r s t cycle 4.10.4 Cold 4.10.5 Low air pressure EIA-53 5ABAE QC300202/USO005
14、 Page 14 o - - - - - - - - - - - - . . - . I - . . - - - . - - - - - . . . - ? - - - . . - . ? - ? . ? . . - . . . - - - - - - - - - - - - . D Conditions of Sample Perf ormance or test (see Note 1) size and requirements ND c r i t e r i o n (see Note i) of accept- a b i l i t y (see Note 31 o - - -
15、- - - - - - P I “ I = o?.o.oo?o.o D 6 27 1 Capacitance Temperature: Upper category temperature (+125 Cl Duration: 16 h. Visual N o v i s i b l e examination damage and no leakage of electrolyte Severity b: 55 C Temperature: Lower category temperature (-55 Cl Duration: 2 h Visual No v i s i b l e exa
16、mination damage and no leakage of e l e c t r o l y t e A i r Pressure : 8.5 kPa Temperature: 15 to 3 5 c Duration: 5 min. Last Minute of test: UR TABLE I V (continued) Copyright Electronic Components, Assemblies & Materials Association Provided by IHS under license with ECA Licensee=IHS Employees/1
17、111111001, User=Wing, Bernie Not for Resale, 03/29/2007 23:49:18 MDTNo reproduction or networking permitted without license from IHS -,-,- E I A 535ABAE 87 m 3234600 0074058 5 m EIA-535ABAE QC300202/usooos Page 15 TABLE IV (Sub-group C1B - continued) 4.10.5.3 Intermediate measurement 4.10.6 Damp hea
18、t, cyclic, test Db, remaining cycles 4.10.7 Sealing 4.10.8 Final measurements Visual examination Severity b: 55 C 5 cycles , No voltage applied Not applicable Visual examination L-akage current. Capacitance Tangent of loss angle N o breakdown , f lash-over or harmful de- formation of the case N o v
19、i s i b l e damage and no leakage of electrolyte Legible marking Teble 2 (Cf-Ci)/Ci: + # - 5 % of value measured i n 4.10.1 and + # - 8% of value measured i n 4.3.1 or 4.6.1 as applicable Table 2 Sub-group C2 4.11 Damp heat, 4.11.1 I n i t i a l 4.11.2 Final steady state measurement measurements Dur
20、ation:21 days Capacitance Visual examination Leakage current 69 N o v i s i b l e I damage and no leakage of e l e c t r o l y t e I Legible marking Table 2 Copyright Electronic Components, Assemblies & Materials Association Provided by IHS under license with ECA Licensee=IHS Employees/1111111001, U
21、ser=Wing, Bernie Not for Resale, 03/29/2007 23:49:18 MDTNo reproduction or networking permitted without license from IHS -,-,- E I A 535ABAE 87 3234b00 0074059 7 EIA-535ABAE QC300202/USO005 Page 16 TABLE I V (Sub-group C2 - continued) C-apac i tanc e Tangent of l o s s angla insusation resistance of
22、 the external insulation Voltage proof of the external insulation (Cf-Ci)/Ci: + f . 5 % of value measured i n 4.11.1 1.15 times Table 2 100M ohms No breakdown or f 1 ashover Subgroup C3 4.12 Endurance 4.12.1 I n i t i a l measurement 4.12.3 Final measurements 3 Duration: 2000 l- 12 u n i t s a t +12
23、5 C, U c 12 u n i t s a t *85 C f U r Recovery: 1 6 h Capacitance Visual examination Leakage current Capacitance Tangent of loss angle 3 24 1 Reference Value N o v i s i b l e Legible marking damage Table 2 (Cf-Cil/Ci: 10% of value measured i n 4.12.1 Table 2 Copyright Electronic Components, Assembl
24、ies & Materials Association Provided by IHS under license with ECA Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/29/2007 23:49:18 MDTNo reproduction or networking permitted without license from IHS -,-,- E I A 535ABAE 87 W 3234600 0074060 3 W Clause number and T e s t (See
25、Note 1) EIA-535ABAE QC300202/USO005 Page 17 TABLE I V (continued) D or ND Conditions of test (see Note 1) Sample s i z e and c r i t e r i o n of accept- abil i t y (see . . Note 3 ) -o- P In I = Performance requirements (see Note 1) Sub-group C4A 4.13 Surge 4.13.1 I n i t i a l measur emen t : 4.13
26、.3 Final measurements Number of cycles: 1000 i u n i t s at: 125 C 3 units at 85 C P ro tec t ive resistor: f O O C ohms +t-LO% Duration of charge: 30 s Duration of dis- charge: 5 min 30 s Capacitance Leakage current Capacitance Tangent of loss Visual angle examination - Not more than 1 defective fo
27、r Subgroups L2 6 1 Reference Value Table 2 (Cf-Ci) /Ci: C l = 10% of value measured in 4.13.1 ,= 1 . 3 times Table 2 No v i s i b l e damage and no leakage of e l e c t r o l y t e C4A and C4B combined-.- Copyright Electronic Components, Assemblies & Materials Association Provided by IHS under licen
28、se with ECA Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/29/2007 23:49:18 MDTNo reproduction or networking permitted without license from IHS -,-,- E 68-5 3 5 AB BE QC300202/US0005 Page 18 D or ND Clause number and Test (see Note 11 Conditions of test (see Note 1) Sample s
29、ize and criterion of accept- abil i ty (see Note 3 ) - P l n t Perf ormance requirements (see Note 11 _- t b t more than 1 defective for. Subgroups C4A and C4B combined- Sub-group C4B I D I 11216 I 1 I Copyright Electronic Components, Assemblies & Materials Association Provided by IHS under license with ECA Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/29/2007 23:49:18 MDTNo reproduction or networking permitted without license from IHS -,-,-
链接地址:https://www.31doc.com/p-3754984.html