环境工程硕士学位论文-复杂多金属硫化矿选矿废水处理与回用工艺研究.doc
《环境工程硕士学位论文-复杂多金属硫化矿选矿废水处理与回用工艺研究.doc》由会员分享,可在线阅读,更多相关《环境工程硕士学位论文-复杂多金属硫化矿选矿废水处理与回用工艺研究.doc(78页珍藏版)》请在三一文库上搜索。
1、湖南农业大学 硕 士 学 位 论 文 复杂多金属硫化矿选矿废水处理与 回用工艺研究 二 O 一二年六月 分类号 密 级 U D C 单位代码 湖南农业大学 硕 士 学 位 论 文 复杂多金属硫化矿选矿废水处理与回用 工艺研究 Study on The Treatment and The Reuse of Complex Poly-metallic Sulphide Ore Dressing Wastewater 研究生姓名 指 导 教 师 教授 副指导教师 教授 学 科 专 业 环境工程 研 究 方 向 废水处理 提交论文日期 论文答辩日期 答辩委员会主席 论文评阅人 学位授予日期 二 O 一
2、二年六月 独 创 性 声 明 本人声明所呈交的论文是我个人在导师指导下进行的研究工作及取得的研 究成果。尽我所知,除了文中特别加以标注和致谢的地方外,论文中不包含其 他人已经发表或撰写过的研究成果,也不包含为获得湖南农业大学或其它教育 机构的学位或证书而使用过的材料。与我一同工作的同志对本研究所做的任何 贡献均已在论文中作了明确的说明并表示了谢意。 研究生签名: 时间: 年 月 日 关于论文使用授权的说明 本人完全了解湖南农业大学有关保留、使用学位论文的规定,即:学校有 权保留送交论文的复印件和磁盘,允许论文被查阅和借阅,可以采用影印、缩 印或扫描等复制手段保存、汇编学位论文。同意湖南农业大学
3、可以用不同方式 在不同媒体上发表、传播学位论文的全部或部分内容。 (保密的学位论文在解密后应遵守此协议保密的学位论文在解密后应遵守此协议) 研究生签名: 时间: 年 月 日 导师签名: 时间: 年 月 日 摘要 据统计湖南省铅锌矿每天处理量在三万吨左右。按用水量平均 5m3/t 计, 每天产生选矿废水 15 万 m3,年排放选矿废水达 4500 万 m3。选矿废水成分复杂, 含有多种重金属离子、残留选矿药剂及悬浮物,不仅存在重金属污染、有机物 污染,还有重金属与有机物的复合污染,直接排放会对周边生态环境产生严重 的危害。因此开展选矿废水的处理与回用研究,对保护矿区周边生态环境,实 现水资源循环
4、利用及矿山的可持续发展有重大意义。 湖南宝山铅锌矿是国内典型的多金属硫化矿并且伴生有较高价值的金银等 贵金属,日处理规模 500t,年生产按 300 天计,每年处理矿石量 15 万 t,日产 生废水量 2700m3,年产生废水达到 81 万 m3。多金属硫化矿废水净化处理回用 的难度高于单一金属矿选矿废水,废水中的金属离子和选矿药剂如达不到一定 程度的净化,在回用过程中会严重影响金属分离回收指标。 本文以湖南宝山铅锌矿选矿废水为研究对象,结合现场工艺生产流程,主 要进行了以下工作。现场水量水质的查定和分析、废水自然降解试验、废水中 的主要残余重金属离子和浮选药剂对铅锌浮选的影响试验、废水净化处
5、理试验、 废水回用试验,最终实现了废水的循环利用,废水回用率达到 100%。 现场水量水质的查定和分析结果表明:该废水 pH12,悬浮物高难沉降、 CODcr 达到 210 mg/l、Pb2+含量达到 6.21mg/l。 废水自然降解试验结果表明:通过 24 个小时的自然降解,废水 pH 值几乎 不变;悬浮物、CODcr、Pb2+去除率分别达到:50%,25.6%,43.6%。废水经过 自然沉降后水质达不到污水综合排放标准。废水中重金属离子(主要指 Pb2+) 、 残留选矿药剂(主要指捕收剂、起泡剂)等对铅锌浮选的影响试验结果表明: 废水中残留的大量 Pb2+和浮选矿药剂对铅锌浮选造成比较大的
6、影响,铅精矿品 位、铅回收率,锌精矿品位、锌回收率都有较大下降。 废水处理试验考察了混凝沉降、活性炭吸附、氧化剂氧化等方法对该废水 的处理净化效果。混凝沉降试验确定了最佳混凝剂为 DA-1,最佳用量为 60mg/l;经过混凝沉降后废水中 Pb2+含量由 6.21mg/l 降到 1.15mg/l;CODcr 值 由 210 mg/l 降到 105mg/l;SS、硫化物都达到污水综合排放标准一级标准。活 性炭吸附试验确定了活性炭用量为 150 mg/l,最佳吸附时间为 30min。经过吸 附后废水中 CODcr 由 106 mg/l 下降到 77 mg/l,Pb2+含量由 1.15mg/l 下降到
7、 0.95mg/l。氧化试验最终确定氧化剂为 ClO2,最佳用量为 40mg/l。处理后废水 中 CODcr 达到污水综合排放标准一级标准。 废水回用试验结果表明:用经过“酸碱中和-混凝沉淀-吸附-氧化-澄清-回 用”净化处理的废水进行闭路试验,对选矿药剂制度的微调,处理水闭路试验 结果和新鲜水闭路试验结果相近。 处理水回用后试验指标为:铅精矿含铅 55.78%、含锌 2.17%、铅的回收率 达到 95.22%;锌精矿含锌 55.26%、含铅 0.68%、锌回收率达到 95.44%。 新鲜水闭路试验指标为:铅精矿含铅 56.75%、含锌 1.89%、铅的回收率达 到 95.71%;锌精矿含锌
8、55.08%、含铅 0.64%、锌回收率达到 96.00%。 试验为实现有色金属矿山废水零排放,水资源综合利用提供了技术参考。 关键词关键词:选矿废水;混凝沉淀;吸附;氧化;零排放;选矿指标; ABSTRACT According to the statistics 9 the produces of Hunan lead-zinc ore is about thirty thousand tons each day produces. The average water of lead-zinc ore is 5 m3 per ton, it will produces nearly one
9、 hundred and fifty thousand tons of dressing wastewater daily, nearly forty-five million tons of dressing wastewater yearly. It have various substances in the dressing wastwater including a certain amount of heavy mental ions, residue mineral processing reagents, high content of SS and etc. Not only
10、 have the single pollution such as heavy metal pollution and organic pollution but also have the combined pollution. Hence, devastating influences must generate to the surrounding ecological environment, if discharged dressing wastewater without any management and controlling. Accordingly, it is ver
11、y important to take measures in controlling and reusing the dressing wastewater whether to consider in protecting the mining surrounding ecological environment,or realizing water resources reclying and sustainable development of the mining. Hunan Baoshan lead-zinc plant is a domestic typical polymet
12、allic sulifide ore and associated with high grade of silver and gold. The produces is about five hundred tons per day, the annual production time is about three hundred day,it will produces nearly one hundred and fifty thousand tons of green ore yearly and nearly eighty hundred and one thousand wast
13、ewater yearly. The wastewater treatment methods of multi-metal ore is more difficulty than the single ore.If the heavy metals and the mineral processing reagents can not reach the degree of purification,it will make a serious affect in heavy metal separation and recovery. In this dissertation, the d
14、ressing wastewater is from Baoshan lead-zinc plant.Basing on the industry production procedures, the text mainly carried out the following works: The analysis and the check of the wastewater; Wastewater natural degradation test; The influence of heavy metal ions and residue mineral processing reagen
15、ts to lead -zinc flotation; Wastewater treatment test; Wastewater reuse test. Finally, the dressing wastewater successfully reused and realized the zero discharge. The results of the analysis and the check of the wastewater show that: The dressing wastewater pH 12, high suspended solids and difficul
16、t to settlement,CODcr reach 210 mg/l, Pb2+content reaches 6.21 mg/l. The results of wastewater natural degradation test show that: Through 24 hours of natural degradation, wastewater pH value almost unchanged,The removal rate of SS, CODcr, Pb2+ achieved50%, 25.6%, 43.6% respectively. Water quality c
17、an not reach the emissions standards. The results of the influence of heavy metal ions and residue mineral processing reagents to lead - zinc flotation show that:It have a great influence to the lead-zinc flotation.the concentrate and the recovery of lead, the concentrate and the recovery of zinc de
18、clined dramatically. The wastewater treatment test included the following jobs:Coagulation,Activated Charcoal adsorption,Oxidation.The coagulation test identified DA-1 was the best coagulant , best dosage was 60mg/l.After the coagulation,the Pb2+content dropped from 6.21mg/l to 1.15mg/l.The CODcr dr
19、opped from 210mg/l to 105mg/l,SS and sulfide reached the emissions standards. The adsorption test identified the dosage of activated charcoal was 150mg/l, the best adsorption time was 30 min. After adsorption,the Pb2+content dropped from 1.15mg/l to 0.95mg/l, the CODcr dropped from 106mg/l to 77mg/l
20、,The oxidation test identified the ClO2,was the best oxidant and the dosage was 40mg/l. after the oxidation the CODcr mg/l less than 50mg/l. The results of wastewater reuse test show that:Adopted the following process to dispose the dressing wastewater”regulation pH-coagulation -Absorption-ClO2 oxid
21、ation-Clarification-Reuse“ the flotation index is nearly the same with that of fresh water. The indexes of the treatment-water were followed as: Lead content in lead concentrate is 55.78% , zinc content in lead concentrate is 2.17%, the lead recovery is 95.22%. Zinc content in zinc concentrate is 55
22、.26% , lead content in zinc concentrate is 0.68%,the zinc recovery is 95.44%. The indexes of the fresh water were followed as: Lead content in lead concentrate is 56.75% , zinc content in lead concentrate is 1.89%, the lead recovery is 95.71%. Zinc content in zinc concentrate is 55.08%, lead content
23、 in zinc concentrate is 0.64%, the zinc recovery is 96.00%. Test will provide the technical reference for realizing the nonferrous metal mining waste- water zero emissions and water resources comprehensive utilization. Key word :dressing wastewater;coagulative precipitation; adsorption; oxidation;ze
24、ro discharge; beneficiation indexes I 目录 第一章 文献综述1 1.1 选矿废水的来源和特点1 1.1.1 选矿废水的来源.1 1.1.2 选矿废水的特点.1 1.2 选矿废水中有害物质对环境的危害2 1.2.1 选矿废水中重金属离子对环境的危害.2 1.2.2 选矿废水中残留选矿药剂对环境的危害.3 1.3 选矿废水净化及资源化应用现状5 1.4 本课题的来源、研究思路及意义10 第二章 试验研究12 2.1 试验仪器及设备12 2.2 试验药品12 2.3 试验矿样13 2.4 试验方法14 2.4.1 废水自然净化试验.14 2.4.2 废水直接回用
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 环境工程 硕士学位 论文 复杂 金属 硫化 选矿 废水处理 用工 研究
链接地址:https://www.31doc.com/p-3957303.html