YZP系列样本要点.pdf
《YZP系列样本要点.pdf》由会员分享,可在线阅读,更多相关《YZP系列样本要点.pdf(14页珍藏版)》请在三一文库上搜索。
1、YZP系列变频调速三相异步电动机 YZP series frequency speed control three-phase asynchronous motor 1. 概述 YZP系列冶金及起重用变频调速三相异步电动机, 用于驱动各种型式的起重机械及其他类似设备的专用 产品;是以变频调速装置为供电电源的专用电动机。能与国内外各种变频装置配套,组成变频调速系统。电动机调 速范围广、过载能力强、运行稳定、可靠、效率高。因此,它特别适用于那些短时或断续运行,频繁地起动、制动、 有时过负荷及显著振动与冲击的设备。 2、使用条件 海拔不超过1000m 能正常运行。 F 级适用于环境空气温度在-20到
2、 40之间,H 级适用于环境空气温度在-20 到 60之间。相对湿度小于90%。 3、基本型式 标称电压: 380V 基频: 50Hz, 1-50Hz 恒转矩调速,50-100Hz 恒功率调速 防护等级: IP54 绝缘等级: F 级或 H 级 冷却方式:风机冷却(IC416) 基准工作制:S3-40% 安装方式: B3( 112400) 、B5(112250) 、 V1(112315) 、B35(132315) 定子接线方式:160 及以下电机定子绕组为Y 接法; 180 及以上电机定子绕组为接法 注:根据用户要求,可带超温保护开关、防潮加热带、电磁制动器、编码器及超速开关等,可根据用户要求
3、提 供基频 50Hz以下的电机。 4、冷却风机型式 标称电压: 380V 基频: 50Hz 基准工作制:S1 对应机座号的轴流风机功率见表1 表 1 对应机座号的轴流风机功率 (Table1 Number of frame and fan power) 机座号 Number of frame 112 132 160 180 200 225 250 280 315 355 400 450 轴流风机功率 Drive motor of fan Output power (W) 90 40 80 80 150 200 230 230 350 600 1100 1100 注:根据用户要求,可采用用离心风
4、机的冷却. 对应机座号的离心风机功率见表2 表 2 对应机座号的离心风机功率 (Table2 Number of frame and centrifugal fan power) 机座号 Number of frame 132 160 180 200 225 250 280 315 355 400 450 风机型号 type of centrifugal fan L-04 L-05 L-06 L-064 L-08 L-11 风机电机功率 power of centrifugal fan motor 60W 180W 370W 1.1 kW3 5.5kW 风机电机极数 pole of centr
5、ifugal fan motor 2 2 2 2 2 4 风机必须由独立电源供电。 1. General YZP series VVVF adjustable speed motors for metallurgy and crane are specially used for driving various cranes and other similarity equipment. The YZP series use frequency conversion adjustable speed power and can be used with various variable fre
6、quency units at home and abroad The YZP series have wide adjustable speed range, high overload capacity, high reliable, high efficiency. The YZP series are very suitable the machine which frequency start and stop or interrupted duty with starting, braking, inverse frequently. 2. Operation condition
7、The motor can run normally when the elevation not more than 1000m. The environment temperature for class F is from -20 to 40 Celsius degree ,for H class from -20 to 60 Celsius degree. Relative humidity less 90%. 3. Base mode rated voltage: 380V. base frequency: 50Hz, 1-50Hz constant torque adjustabl
8、e speed, 50-100Hz constant power adjustable speed protection Class:IP54 insulation class: F or H cooling mode: fan cooling ( IC416) base operating duty : S3-40% install mode: B3 (112450) 、B5(112250) 、V1( 112315) 、B35(132315) winding connection: Y to 160 and below; to 180 and above According to the a
9、greement, the following are optional: over-temperature protection, dampproof heating belt, brake, rotary encoder, over-speed switch. 4 Cooling fan Rated voltage: 380V. Base frequency: 50Hz, Base operating mode : S1 According to the demand of customer, we can provide centrifugal fan. The power of dri
10、ve motor shown in table1 and table 2. Fan must be powered independently! 5. YZP 系列变频调速电动机型号意义:Significance of models of YZP series frequency (speed) motor Y Z P 160 L - 4 异步电机极数 Asynchronous motor Number of poles 冶金及起重用机座长短代号 For metallurgy and liftingLong and short code of frame 变频调速中心高( mm ) Frequ
11、ency conversion and Height of center (mm) speed adjustment 注:电机带带风机、制动器或编码器,则其型号加上其对应的符号。 Note: In case that the motor is equipped with fan moter 、brake or rotary encoder, the corresponding characteristic 6. 变频电机基准工作制为S3-40%,280 及以下中心高其它工作制功率换算关系见表3,315 及以上中心高其它工作 制功率换算需与厂家联系 表 3 工作制功率换算关系(Table 3 d
12、uty and power) 工作制 duty S1 S2 S3 S4 100% 30 minutes 60 minutes 15% 25% 40% 60% 150 times/hour 300 times/hour 功率折算关系 Conversion relation of powerr 1.00 1.10 1.00 1.35 1.10 1.00 0.80 0.83 0.73 6.The base duty of the frequency conversion motor is: S3-40%, the conversion relation with other characters o
13、f service is as table 3: 7. YZP 系列电机主要技术参数: Main technical parameters of YZP series motor (only for reference, see the nameplate of the motor for details): 电机为 4 极表( 1)motor with four poles (table 1) 型号 model 标称 功率 nominal power (kw) 额定 电流 rated current (A) 额定转矩 rated torque (N.m) 额定转速 rated speed (
14、r/min) 堵转转矩/额定转矩 rated torque / locked rotor torque (1Hz ) 最大转矩 /额定转矩 rated torque / max. torque (50Hz) 转动惯量 moment of inertia kgm 2 重量 weight (kg) YZP100L2-4 2.2 6 15 1390 1.522.90.0165 35 YZP112M1-42.2 6 15 1390 1.52 3.0 0.0170 50 YZP112M2-43 8.0 20.5 1400 1.52 3.0 0.0173 53 YZP112M3-4 4.0 9.5 27
15、1415 1.52 3.0 0.0175 55 YZP132S-4 5.5 12.2 36 1450 1.52 3.1 0.048 78 YZP132M-4 7.5 16.9 48 1450 1.52 3.2 0.056 92 YZP160M1-4 7.5 16.9 48 1450 1.52 3.2 0.09 105 YZP160M2-4 11 23 71 1465 1.52 3.4 0.11 115 YZP160L-4 15 30 98 1465 1.52 3.5 0.125 130 YZP180M-4 18.5 37 120 1465 1.52 3.5 0.30 195 YZP180L-4
16、 22 47 146 1450 1.52 3.3 0.35 210 YZP200L1-4 30 57 195 1470 1.52 3.5 0.263 280 YZP200L2-4 37 70 240 1470 1.52 3.2 0.273 300 YZP225S-4 37 70 241 1465 1.52 3.2 0.273 360 YZP225M-4 45 87 293 1465 1.52 3.3 0.469 400 YZP250M-4 55 102 356 1475 1.52 3.0 0.66 480 YZP280S1-4 63 117 408 1475 1.52 3.0 1.08 555
17、 YZP280S2-4 75 136 486 1475 1.52 3.0 1.12 572 YZP280M-4 90 165 583 1475 1.52 3.0 1.15 677 YZP315S1-4 110 200 715 1470 1.52 3.1 3.11 990 YZP315S2-4 132 231 858 1470 1.52 3.1 3.11 1023 YZP315M1-4 160 281 1040 1470 1.52 3.0 3.62 1092 YZP315M2-4 200 352 1299 1470 1.52 3.0 4.13 1161 YZP315L-4 220 387 142
18、8 1471 1.52 3.2 4.94 1720 YZP355Ma4 220 386 1420 1480 1.52 3.1 5.75 1454 YZP355M-4 250 440 1593 1480 1.52 3.1 5.75 1870 YZP355L-4 315 550 2008 1480 1.52 3.1 6.79 1870 电机为 6 极表( 2) motor with six poles (table 2) 型号 model 标称 功率 nominal power (kw) 额定 电流 rated current (A) 额定 转矩 rated torque (N.m) 额定转速 r
19、ated speed (r/min) 堵转转矩/额定 转矩 rated torque / locked rotor torque (1Hz ) 最大转矩 /额 定转矩 rated torque / max. torque (50Hz) 转动惯量 moment of inertia kgm 2 重量 weight (kg) YZP112M-6 2.2 6.0 22.5 930 1.52 3.0 0.020 55 YZP132S-6 3 7.5 30 960 1.52 3.1 0.0525 8 YZP132M1-6 4 9.8 40 960 1.52 3.1 0.0562 92 YZP132M2-
20、6 5.5 12.7 55 960 1.52 3.1 0.0575 97 YZP160M-6 7.5 18 74 970 1.52 3.0 0.1325 132 YZP160L-6 11 26 108 970 1.52 3.1 0.1775 152 YZP180M-6 11 22 108 970 1.52 3.1 0.1775 220 YZP180L-6 15 30 148 970 1.52 3.2 0.31 220 YZP200L1-6 18.5 37 182 970 1.52 3.2 0.312 230 YZP200L2-6 22 45 214 980 1.52 3.3 0.315 250
21、 YZP200L3-6 30 60 290 980 1.52 3.0 0.361 290 YZP225M1-6 30 60 290 980 1.52 3.0 0.4 300 YZP225M2-6 37 73 360 982 1.52 3.0 0.547 318 YZP250M1-6 37 71 359 985 1.52 2.9 0.834 415 YZP250M2-6 45 85 438 982 1.52 2.9 0.834 430 YZP280S1-6 45 85 438 982 1.52 2.9 0.9 450 YZP280S2-6 55 102 533 985 1.52 3.0 1.39
22、 550 YZP280S3-6 63 130 611 985 1.52 3.0 1.5 580 YZP280M-6 75 143 727 985 1.52 3.1 1.65 620 YZP315S1-6 75 136 727 985 1.52 3.1 4.01 915 YZP315S2-6 90 170 862 985 1.52 3.1 4.11 915 YZP315M1-6 110 206 1066 985 1.52 3.2 4.78 1025 YZP315M2-6 132 246 1279 985 1.52 3.0 5.45 1098 YZP315L-6 160 297 1551 985
23、1.52 3.0 6.12 1165 YZP355M1-6 200 369 1949 980 1.52 3.5 8.02 1690 YZP355M2-6 220 403 2144 980 1.52 3.5 9.36 1730 YZP355L-6 250 450 2436 980 1.52 3.5 10.54 1820 YZP400L1-6 315 551 3070 980 1.52 3.5 12.5 2400 YZP400L2-6 330 585 3215 980 1.52 3.5 13.9 2500 YZP400L3-6 355 625 3428 989 1.52 3.5 15.6 2800
24、 YZP450L1-6 400 710 3839 995 1.52 3.6 37.8 3400 YZP450L2-6 450 810 4319 995 1.52 3.6 44 3800 YZP450L3-6 500 920 4798 995 1.52 3.6 45 4000 电机为 8 极表( 3)motor with eight poles (table 3) 型号 model 标称 功率 nominal power (kw) 额定 电流 rated current (A) 额定转 矩 rated torque (N.m) 额定转 速 rated speed (r/min) 堵转转矩/ 额定
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- YZP 系列 样本 要点
链接地址:https://www.31doc.com/p-5198600.html