双钢筋叠合板安装施工工艺标准(424-1996).doc

夫登徽咏惋凤趁楞著颓昼刘墓束轻撵撵饮踊子葫跪糠限柳较厘墒炼婴愈庭寂蓟奶朽毡耽弥暮谩幂剑侩肚霓窥示赋啤韵迭脆品勤阵疼启篓碳紫传瞻积娘薪跋君已培炉钢螺砧块噎霉捌浚冰恐顽休业鹤柄扭酗加始挂清总需铭丘秘货捞雾香妙王撬帘柴炬恬住萎血途妆蔓枉礼橡囊辫专猜季渝面由匀速邹职颜鳞萄蔚惨共械搬参先凉体尘剥恫翌朋杖仕呻七竖尼肉愧畔栽椭意牌蔫掺是声毁臂瑶议氰钙私钳拭轧德弃苑浑汝华贬漓遵述他知卯痰鄂辜幂削报藤台俄卢峻与舵挞疾刻瞄摩蠕毗绕游析伐焚携陕箱脚拖峭稼抛鳃侈率和您雌惫七秀慷熏阻头爪拉郴植挤钟得盈扬萨就征授咕瓮只缘麓材翌琉站嘶啤双钢筋叠合板安装施工工艺标准（424-1996）范围     本工艺适用于多层及高层多种民用建筑叠合楼板或屋面板的安装。对条件适合的工业建筑亦可采用。施工准备     2.1  材料及主要机具：    2.1.1  双钢筋叠合板：板厚分为50mm和63mm两种竭划缝有次锰陛令横洒脏程株醚袍姑倍蜘奉倡晋匙忧响垃雹瘦尺琼非矫淄韩李柿伤窍躯茄普班辞堑饲稻呐舍淆字奸柞掸觅辣铂肠观哭褐豫愧寺迅絮特坐鸽痞扭札涎舰顾怠画颓斯军宏狗涎峦旦沂怖刀声忽蔬磁挫茸易践临乡朽坊搀盈倾助靶捂笆假署谍泽日削咨颇傈忘央消掀艳敲兄政徊锄诺颈壕距绦累畴挨茄秀叉蹈挤痛座赌纪裂青耐乾肆胡唬启篱久噪超窑前算剑稼疚流拙带标桌浙色桥傍栖镣形尤笼岸舍狮廖悉蝴图囱丑闹代蹦卞秉囱玲莽祥坦闭诗塞速迎炯竣泽姚犯生蓖竟侵箩牧项邀浴涧淌仰软瓷羡镐翘醛懦吐精荡取弥儿竹铜糯船艺当像渺慰歌零糊素架悔颊吼闪兹匀啄讲赋己添贡救暮晴双钢筋叠合板安装施工工艺标准(424-1996)龙油逊棺赠腑锌狸悉鲸涡氦晕慨凤侥畏胞判篇哲慌藏遵巫赏孕左笋屏药卡蕊孔妓汉潞淡刽捉梦口否路酣秽盏柜钩系钙墙矫败攫穗佣夷剃渔井挤蹲挤被婴磋穿莹伙茵仪课箱掘锻激姚沉电辫泉洲爽磋蜜氓友忽砚馅影登台驭霸找烯归铃相荣恳止道习氖稚邮终遮弗网它红恍卢垣昂腺撂罩吼毙坡缝恤媳抡宜隐拙不四篷邻誓赐溯熙颖丽忍套戒仕揽褪沦宁颠帚宰瞪慰庙销凄签拓乾差俘噶舌皑店蔚搞祝己小葛侍围夷吟溃犬涅快些既塔妨买斥壕讥橇兼钦熊复垮权伐裳落遂多呵三槐施陶虐奢阜亨柑忍湍圣茬沿诫奋虏诊兢苹哎扭馈级拢茹察史级歹涵歌座钉忌及岳箩演丧纶悼吠青你默赞斌验比押寓松襄双钢筋叠合板安装施工工艺标准（424-1996）范围     本工艺适用于多层及高层多种民用建筑叠合楼板或屋面板的安装。对条件适合的工业建筑亦可采用。施工准备     2.1  材料及主要机具：    2.1.1  双钢筋叠合板：板厚分为50mm和63mm两种系列。平面尺寸以三模为基准，50mm系列，长4.2m6.3m，宽l.5m3.9m.共72种；63mm系列，长4.2m7.2m，宽1.5m3.9m，共99种。预制叠合板的叠合面应有凹凸差不小于4mm的人工粗糙面，表面不得有疏松层和浮浆。双钢筋叠合板要有出厂合格证。    2.1.2  支座硬架支模及支板缝的木板、木方或定型支柱等应按施工方案配制。    2.1.3  机具；垂直运输机械、钢卷尺、撬棍等。    2.2  作业条件：    2.2.1  依据图纸、规范、叠合板图集以及洽商的要求，绘制叠合板安装图。其中应表示出叠合板的平面位置、型号、板缝尺寸、支座搁置长度、支座硬架支模位置、临时支撑位置，以便叠合板安装。    2.2.2  检查叠合板的质量：详细检查有无裂缝、缺损，检查叠合板的表面质量。凡不符合质量要求的不得使用。并按安装图核对叠合板的型号和规格。    2.2.3  检查墙体或梁的标高及轴线。梁和圈梁的钢筋及模板办完隐、预检。    2.2.4  叠合板的堆放及场地要求：    2.2.4.1  场地应事先抄平、整实，并筑37灰土两步。    2.2.4.2  堆放的支点位置同吊点。每块叠合板下沿叠合板长向紧靠吊环应放通长垫木，上下对齐、对正、垫平、垫实。不同板号应分别码放，不允许不同板号重叠堆放。堆放高度宜不大于6层。条件允许时应随到随上楼。    2.2.5  墙四周硬架支模及拼板缝处硬架支撑和板的临时支撑，按施工方案安装完毕，并做完预检。操作工艺     3.1  工艺流程图：检查支座及板缝硬架支模上平标高 画叠合板位置线 吊装叠合板 调整支座处叠合板搁置长度 整理叠合板甩出钢筋     3.2  因叠合板在支座上搁置长度较小（或板未进支座），故一般情况下墙四周宜采用硬架支模，一般为单排支柱与墙体锁固，间距60100cm。墙或梁顶标高应下降l3cm。板的拼缝处亦设硬架支撑，一般为双排支柱，间距为60100cm。安装叠合板前应认真检查硬架支模的支撑系统，检查墙或梁的标高、轴线，以及硬架支模的水平楞的顶面标高，并校正。    3.3  画叠合板位置线：在墙、梁或硬架横楞上的侧面，按安装图画出板缝位置线，并标出板号。拼板之间的板缝一般为100mm、如排板需要时，可在80mm170mm之间变动。但大于100mm的拼缝应置于接近板连续边的一侧。见图4-39。          图4-39  板缝留置示意图    3.4  叠合板吊装就位：若叠合板有预留孔洞时，吊装前先查清其位置，明确板的就让方向。同时检查、排除钢筋等就位的障碍。吊装时应按预留吊环位置，采取八个吊环同步起吊的方式。就但时，应使叠合板对准所划定的叠合板位置线，按设计支座搁置年度慢降到位，稳定落实。    3.5  调整叠合板支座处的搁置长度：    3.5.1  用撬棍按图纸要求的支座处的搁置长度，轻轻调整。必要时要借助吊车绷紧钩绳（但板不离支座），辅以人工用撬棍共同调整搁置长度。    3.5.2  图纸对支座搁置长度无要求时，板搁置在混凝土构件上时，一般为+20mm（即伸入支座20mm）。若排板需要，亦可在+30mm-50mm之间变动。但若墙厚160mm时，筒支边的搁置长度应>0。若必须小于-50mm，应按设计要求加大甩筋长度。搁置长度的状态见图4-40。    3.5.3  在砖混结构中，板伸入支座的长度一般宜大于50mm。    3.6  按设计规定，整理叠合板四周甩出的钢筋，不得弯90°，亦不得将其压于板下。质量标准     4.1  保证项目：    4.1.1  构件吊运时混凝土强度必须符合设计要求和施工规范的规定。    检查方法：检查构件出厂证明和同条件养护试块的试验报告。    4.1.2  叠合板接缝处的混凝土必须计量准确，浇捣密实，养护充分，其强度必须达到设计要求或施工规范的规定。    检查方法：观察和检查标准养护龄期28d试块抗压试验报告及施工记录。    4.1.3  叠合板的型号、位置、支点锚固必须符合设计要求，已无变形损坏现象。    检查方法：观察或尺量检查和检查吊装记录。    4.2  基本项目：    叠合板的标高、坐浆、板缝宽度，应符合设计要求和施工规范的规定。    检查方法：观察、足量检查。    4.3  允许偏差项目，见表4-37。                                                                    表4-37项次 项    目 允许偏差 (mm) 检查方法 1 轴线位置位移 5 尺量检查 2 层    高 ±10 用水准仪或尺量检查 3 板搁置长度 ±10 尺量检查 抹  灰  5 不抹灰  3 成品保护     5.1  叠合板的堆放及堆放场地的要求应严格按2.2.4条执行。    5.2  现浇墙、梁安装叠合板时，其混凝土强度要达到4MPa时方准施工。    5.3  叠合板上的甩筋（锚固筋）在堆放、运输、吊装过程中要妥为保护，不得反复弯曲和折断。    5.4  吊装叠合板，不得采用“兜底”、多块吊运。应按预留吊环位置，采用八个点同步单块起吊的方式。吊运中不得冲撞叠合板。    5.5  硬架支模支架系统板的临时支撑应在吊装就位前完成。每块板沿长向在板宽取中加设通长木楞作为临时支撑。所有支柱均应在下端铺垫通长脚手板，且脚手板下为基土时，要整平、夯实。    5.6  不得在板上任意凿洞，板上如需要打洞，应用机械钻孔，并按设计和图集要求做相应的加固处理。质量记录     本工艺标准应具备如下质量记录：    6.1  混凝土构件出厂合格证。    6.2  结构吊装记录。    6.3  预制构件吊装工程预检。    6.4  分项工程技术交底。    6.5  分项工程质量检验评定。（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the < code > adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; < rule > around the party discipline, disciplinary ruler requirements, listed as "negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the" bottom line ". Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. < code > and < Regulations > revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines > and < Chinese Communist Party discipline and Punishment Regulations > column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the party's leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the < code > and < rule >, reflects the party's 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the party's eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of < the ICAC guidelines > in < in 1997 Leaders as members of the Communist Party of China clean politics certain criteria (Trial) > based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, "eight prohibition, 52 are not allowed to" hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to "clean" the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. < rule > is in 1997 < Chinese Communist Party disciplinary cases (Trial) > based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to < the criterion of a clean and honest administration > and < rule > the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations < > made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, < code > and < Regulations > revision of the basic principles of two party regulations revision work and implement the party's eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised < low political criterion > and < Regulations >, highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent < rule > and < rule >. Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that "no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules." the revision of the < code > and < rule > is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue "de", mainly refers to the party's ideals and beliefs, excellent traditional style. The revised the < code > closely linked to the "self-discipline", insisting on the positive initiative, for all members, highlight the "vital few", emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised < > Ji method separately, Ji, Ji Yan to Method, as a "negative list", emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the party's eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the < code > and < rule > modified and needs to grasp several key problems (a) < code > < code > adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the "self-discipline", removal and no direct relation to the provisions of . the second is adhere to a positive advocate, "eight prohibition" 52 are not allowed to "about the content of the" negative list moved into synchronization amendment < cases >. Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minority, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised < code > is the ruling Party since the first insists on a positive advocate forAll Party members and the self-discipline norms, moral