qo一次风机、二次风机和侧墙冷却风机技术要求.doc

济南市第二生活垃圾综合处理厂焚烧发电厂焚烧间一、二次风机和侧墙冷却风机招标技术参数2009年6月1. 工程概况：项目名称：济南市第二生活垃圾综合处理厂焚烧发电厂项目建设单位：光大环保工程技术（深圳）有限公司本项目位于济南市济阳县孙耿镇香火高家村南侧园地，日焚烧处理生活垃圾2000吨，配置4台500t/d炉排型垃圾焚烧炉，年焚烧垃圾66.67万吨。2. 主要原始资料2.1 气象特征与环境条件年平均气温：13.6，最高气温42.7，最低气温：-19.7年平均积雪日数14.7天，最大积深19cm。降雨量：年平均降雨量：685mm年最大降雨量：1160mm年最小降雨量：320.7mm湿度：年平均相对湿度58%风向风速：常年主导风向：西南、东北风最大风速：33.3m/s，风力12级以上。无霜期：全年无霜期：230天左右2.2 地震烈度地震烈度： 6度设计基本地震加速度值为0.05g3. 风机技术参数：3.1 设备名称：14一次风机工作制度：连续运行，全年运行至少8000h数量：共32台 (每条焚烧线8台)风机类型：离心风机技术规格额定工况(MCR)最大工况（MR）1 风量（Nm³/h）5.178-7.3589.810风量（m³/h）9.395-13.42018.0372入口静压（Pa(g)）-510/-1030-18303出口静压（Pa(g)）360/73013104静压差（Pa）870/176031305工作温度（）22052356环境湿度()70595%7安装地点焚烧间8风机转速（rpm）30009风机效率()8010 噪音等级（dB(A)）82(距离设备1m外)11控制方式变频控制12绝缘/防护等级F（Class/ IP 54）13 电源（V / Ph / Hz）400 / 3 + N + E / 5014 电机功率(kW)3015 振动要求至少Q6,316 吸风口方向：水平方向吸风17 出风口方向：8台左旋90°垂直向上出风8台右旋90°垂直向上出风3.2 设备名称：5一次风机工作制度：连续运行，全年运行至少8000h数量：共8台 (每条焚烧线2台)风机类型：离心风机技术规格额定工况(MCR)最大工况（MR）1 风量（Nm³/h）21805450风量（m³/h）3947100152入口静压（Pa(g)）-280-17703出口静压（Pa(g)）17010404静压差（Pa）45028105工作温度（）22052356环境湿度()70595%7安装地点焚烧间8风机转速（rpm）30009风机效率()7510 噪音等级（dB(A)）82(距离设备1m外)11控制方式变频控制12绝缘/ 防护等级F（Class/ IP 54）13 电源（V / Ph / Hz）400 / 3 + N + E / 5014 电机功率(kW)1515 振动要求至少Q6,316 吸风口方向：水平方向吸风17 出风口方向：2台左旋90°垂直向上出风2台右旋90°垂直向上出风3.3 设备名称：二次风机工作制度：连续运行，全年运行至少8000h数量：共4台 (每条焚烧线1台)风机类型：离心风机技术规格额定工况(MCR)最大工况（MR）1 风量（Nm³/h）1664031275风量（m³/h）1882356832入口静压（Pa(g)）-270-11403出口静压（Pa(g)）177073204静压差（Pa）204084605工作温度（）355456环境湿度()70595%7安装地点焚烧间8风机转速（rpm）30009风机效率()8010 噪音等级（dB(A)）82(距离设备1m外)11控制方式变频控制12绝缘/ 防护等级F（Class/ IP 54）13 电源（V / Ph / Hz）400 / 3 + N + E / 5014 电机功率(kW)16015 振动要求至少Q6,316 吸风口方向：水平方向吸风17 出风口方向：右旋90°垂直向上出风3.4 设备名称：侧墙冷却风机工作制度：连续运行，全年运行至少8000h数量：共4台 (每条焚烧线1台)风机类型：离心风机技术规格额定工况(MCR)最大工况（MR）1 风量（Nm³/h）6000133352静压差（Pa）2240110503工作温度（）355454环境湿度()70595%5安装地点焚烧间6风机转速（rpm）30007风机效率()808 噪音等级（dB(A)）82(距离设备1m外)9控制方式变频控制10绝缘/ 防护等级F（Class/ IP 54）11电源（V / Ph / Hz）400 / 3 + N + E / 5012 振动要求至少Q6,313 电机功率(kW)7514 吸风口方向：水平方向吸风15 出风口方向：左旋180°水平出风4. 其他要求：4.1 以上风机尺寸必须提交KSBE批准。4.2 以上风机的其他技术参数由设备厂家完善并提交KSBE批准。4.3 所有风机需配带进出口膨胀节。（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the < code > adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; < rule > around the party discipline, disciplinary ruler requirements, listed as "negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the" bottom line ". Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. < code > and < Regulations > revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines > and < Chinese Communist Party discipline and Punishment Regulations > column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the party's leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the < code > and < rule >, reflects the party's 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the party's eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of < the ICAC guidelines > in < in 1997 Leaders as members of the Communist Party of China clean politics certain criteria (Trial) > based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, "eight prohibition, 52 are not allowed to" hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to "clean" the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. < rule > is in 1997 < Chinese Communist Party disciplinary cases (Trial) > based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to < the criterion of a clean and honest administration > and < rule > the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations < > made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, < code > and < Regulations > revision of the basic principles of two party regulations revision work and implement the party's eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised < low political criterion > and < Regulations >, highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent < rule > and < rule >. Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that "no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules." the revision of the < code > and < rule > is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue "de", mainly refers to the party's ideals and beliefs, excellent traditional style. The revised the < code > closely linked to the "self-discipline", insisting on the positive initiative, for all members, highlight the "vital few", emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised < > Ji method separately, Ji, Ji Yan to Method, as a "negative list", emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the party's eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the < code > and < rule > modified and needs to grasp several key problems (a) < code > < code > adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the "self-discipline", removal and no direct relation to the provisions of . the second is adhere to a positive advocate, "eight prohibition" 52 are not allowed to "about the content of the" negative list moved into synchronization amendment < cases >. Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minority, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised < code > is the ruling Party since the first insists on a positive advocate forAll Party members and the self-discipline norms, moral declaration issued to all members of the party and the National People's solemn commitment. > < criterion of a clean and honest administration consists of 4 parts, 18, more than 3600 words. After the revision of the < code >, a total of eight, 281 words, including lead, specification and Party member cadre clean fingered self-discipline norms, etc. Part 3 members low-cost clean and self-discipline, the main contents can be summarized as "four must" "eight code". Lead part, reiterated on ideal and faith, fundamental purpose, the fine traditions and work style, noble sentiments, such as "four must" the principle of requirements, strong tone of self-discipline, The higher request for 6